Professional Documents
Culture Documents
Return to FAQs
WARNING: Make sure the machine has stopped copying / printing and Minutes
that the "Online" and "Job in Memory" LEDs on the User Interface are off
before continuing with the steps below.
CAUTION: Do not remove the new Drum Cartridge from its packaging until instructed to do so.
Exposure to direct sunlight or strong indoor fluorescent lighting for more than two minutes
may cause damage to the photoreceptor.
1. Power the machine off using the power switch on the Control Panel. See the Related Content for
additional information.
2. Prepare a clean, flat surfaced area with paper or cardboard. This is where the used Drum
Cartridge will be placed.
3. Open the Front Door.
4. If the Drum Latch cover is present, remove the screw from the Drum Latch cover using a 5.5 mm
nut-driver or #2 Phillips screwdriver. Discard the screw and Drum Latch cover, as this is not
needed for the new Drum Cartridge.
http://www.support.xerox.com/SRVS/CGI-BIN/WEBCGI.EXE?New,Kb=x_4110_en,Company={683D76C8-B5C5-416E-9754-DD015FDB4F2E},ts=… 1/5
22/9/2560 Fuji Xerox D95 / D110 / D125 Copier-Printer Online Support Solution Replace the Drum Cartridge (Xerographic Module) | Xerox SGP
5. Move handle 2 to the unlocked position.
7. Grasp the Drum Cartridge, press in the Drum Latch, and then carefully pull the cartridge straight
out until the handle on top of the cartridge is visible.
8. Grasp the handle on top of the cartridge, and then completely remove the cartridge from the
printer.
http://www.support.xerox.com/SRVS/CGI-BIN/WEBCGI.EXE?New,Kb=x_4110_en,Company={683D76C8-B5C5-416E-9754-DD015FDB4F2E},ts=… 2/5
22/9/2560 Fuji Xerox D95 / D110 / D125 Copier-Printer Online Support Solution Replace the Drum Cartridge (Xerographic Module) | Xerox SGP
9. Set the Drum Cartridge aside on the paper or cardboard prepared in step 4.
CAUTION: Do not remove the new Drum Cartridge from its packaging until instructed to do
so. Exposure to direct sunlight or strong indoor fluorescent lighting for more than two
minutes may cause damage to the photoreceptor.
CAUTION: Do not allow the blue drum to contact any surface or be exposed to light for
more than two minutes.
14. Holding the cartridge by the handle, carefully align the cartridge with both rails in the printer.
15. Make sure the cartridge is aligned with the rails, and then gently (but firmly) push the cartridge
straight in until it clicks into position.
http://www.support.xerox.com/SRVS/CGI-BIN/WEBCGI.EXE?New,Kb=x_4110_en,Company={683D76C8-B5C5-416E-9754-DD015FDB4F2E},ts=… 3/5
22/9/2560 Fuji Xerox D95 / D110 / D125 Copier-Printer Online Support Solution Replace the Drum Cartridge (Xerographic Module) | Xerox SGP
20. Make sure the machine is operating correctly by making a few copies.
Related Items:
http://www.support.xerox.com/SRVS/CGI-BIN/WEBCGI.EXE?New,Kb=x_4110_en,Company={683D76C8-B5C5-416E-9754-DD015FDB4F2E},ts=… 4/5