3042 WRB
JAW CRUSHER
BASE — PITMAN
Trew
Bs
PART NUMBER _bescniprion
6524-133 _| Base Assembly
8524-477 | Base Caps (See Below)
3
0.
1
2 -
1 | 16 | 1y"-6NC-2 | Base Nuts - G-9uy
1 | 6 |540-Ra__| Base Studs
msl 2 [1 Pipe Plugs zi
2 | 2 [B524-Ai0 | Key Wedge — Upper __|
3 | 2 [e524-B10 | Key Wedge — Lower
és 4 | 8 | 0540-A5 | Key Wedge Bolts
5 | 8 [ps40-a6 | Key Wedge Washers |
[6 [16 | 1-enc-2 | Key Wedge Nuts J
7 | 1 [524-C10 | Hoel Plate — Left
8 | 1 [B524-c10 | Heel Plate — Right
9 | 6 [0540-45 | Heel Plate Bolts
30 | 6 [D540-a6 | Heel Plate Washers
11 | 42 [1-8Nc-2 | Heel Plate Nuts
12 | 1 [See Page 5 | Jaw Plate — Stationary
13 | 1 [See Page 5 _| Jaw Plate — Movable.
[44 [1 [es24-n99 | Pitman
16 | 2 [ay Pitman Pipe Plugs
16 See Page § | Pitman Wedge
i7 | 5 | B524-c17 | Pitman Wedge Bolts |
18 | 5 | 1%" Flat) | Pitman Wedge Washers
[19 [40 [1%"-7No-2 | Pitman Wedge Nuts
Illustrations are representative only and may not appear
Identical to actual units. All base assemblies include all
welded portions of the base plus the base caps and nuts,
Base caps cannot be ordered separately. They are line
bored and part of the base. Be sure to match mark before
removal. They are shown for illustration only. Contact the
factory for further explanation. A variety of jaw plates are
available for each crusher and a complete listing is shown
on page § of these instructions. Pitman wedges may also
vary depending on the jaw plate being used and proper
selection can be made trom page §. Only one reterence
‘number is shown for identical bolts and nuts. Refer to the
quantity required column for the proper quantities. In some
cases, bolts may not require nuts or enter from a different
Position. Quantities and part number listing will reflect,
Such. Safety first — see maintenance and safety
instructions.
Ref: 8M:c524-134p UNIVERSAL ENGINEERING CORPORATION, CEDAR RAPIDS, IOWA 52405
Sec: 100-3042 ‘Subsidiary, the Pettibone Corporation, Chicago Page 2