Professional Documents
Culture Documents
Instructions
1.Summarize verb
1.1 Summarize
PA communication device is a communication accessories which is used with the
respirators.This product can effectively enlarge officers sounds and makes the sound clear and
loud.In addition,it can build long-distance communications with intercom, which makes
collaboration more easily and effectively between staff.The product is exquisite, beautiful
appearance and simple operation.Also the mask is easy to install and clean.
2.Inspection items
Items included in the box:
Mask PA communication device
Microphone housing
Instructions
Two No. AAA 7 batteries
Speakers: 8 ohm
1
4.Parts Description
2
5.Battery Installation:
5.1 Unscrew the two thumb screws counterclockwise, set off the battery cover
5.2 Put the two AAA batteries into the battery compartment in the correct direction and
5.3 When a beep or amplifier does not sound, replace the battery
5.4 When PA communication devices do not mask the long-term, be sure to remove the
6.2 Replace aluminum with a special mask internal microphone accessories (first line leads
from the microphone and make sure the microphone at Figure II in the end and put the
6.3 The microphone is pressed into contact microphone amplifier housing slot and groove
along fixed lines, then cover to mask PA communication device (note the Install button and spring)
and marked the screws on the mask, the last communication with the two fixed mask layering PA
3
Note: Be sure the microphone hole up to make sure it is on the mouth, otherwise
the sound becomes smaller.
7.2 Turn off.When wearing a mask, long press the power switch 3S, LED turns red, while the
speaker issued a "tick" sound;It means it's in working condition, if speaking, sound can be
7.3Lights on and off..When working,press the power button shortly to turn on or off lights.
7.4Manual alarm on and off. When turn on,press the power button shortly and continually
twice to turn on or turn off the sound and light alarm function.
7.5Automatic alarm mode on and off. The boot mode, press the power button three consecutive
times to open or close the alarm mode, and turn on the alarm mode horn "Didi" 2 sound,
the power light turns red; turn off the alarm mode, the speaker issued a "beep beep" 4
sound, the power indicator turns green.When the automatic alarm mode is on: when 30
seconds is not moving, then enter 20 seconds pre-alarm stage, torches flicker, the speaker
beeps when the product subject to vibration, the alarm cancel, otherwise enter the hazard
warning stage, flashes and beeps speed up the frequency, only continuous short press the
4
7.6 When the need for remote intercom calls, PTT flip cover installation and cable connection
with a walkie-talkie, then the receiver will be able to hear the other party to accept the intercom
voice sounds, press the PTT button to talk to the other party can hear your own voice .
7.7 Product use, if the sound significantly reduce or continuous beep, you should change the
batteries.
WARNING
Note:
a. Make sure the microphone hole facing up, insert the contact microphone and microphone slot;
b. When working to ensure that the batteries are charged and the switch is pressed.