Professional Documents
Culture Documents
Old Tank
CPN 57612210
PV 351 – Tower – New Crown for Easy Pullback Cables Replacement
PV 351 – Tower – New Crown for Easy Pullback Cables Replacement
Old Design
PV 351 – Tower – New Crown for Easy Pullback Cables Replacement
PV 351 – Tower – New Crown for Easy Pullback Cables Replacement
PV 351 – Tower – New Crown for Easy Pullback Cables Replacement
PV 351 Heat Developer – New Number CPN 58382660 Tank Aluminum
TSNB
ADS 110518072
PV 351 Rod Support Pin- New Number CPN 58449622
PV 351 Rod Support Pin- New Number CPN 58449622
TSNB
ADS 110420049
ADS 110524078
PV 351 Rod Support Pin- New Number CPN 58449622
PV 351 – Bolting Machine for High Torque
PV 351 – Bolting Machine for High Torque
PV 351 – Bolting Machine for High Torque
PV 351 – Bolting Machine for High Torque
Replacements parts:
New Spacer
PV 351 Twin Compressor- Bearing Spacer CPN 54372040
TSNB
ADS 110611085
PV 351 – Rotary Head Creep – Kit CPN 58458645
PV 351 – Rotary Head Creep – Kit CPN 58458645
PV 351 Fan for COC – New CPN 58452527
PV 351 Fan for COC – New CPN 58452527
PV 351 E – Transformer Oil Level and Oil Specifications
“The proper oil level for the transformer is where the oil would cover only
half way up the top (X1, X2, X3) bushings. Looking through the access
cover from the top at the back of these bushings, you would fill to where the
oil level comes up only mid way on these bushings, they will not be
completely under the oil.
This is the proper oil level at approximately 25 degrees Centigrade. This
oil level will allow for expansion of the oil as the transformer gets hot under
loading. This oil level is based on the transformer being properly level at
filling, if it is tilted, you must allow for this”.
CPN 58262625
Hydraulic Motor
PV 271 / 275 HR 2.5 New Cover and Lip Seal CPN 23198617
PV 271 / 275 HR 2.5 New Cover and Lip Seal CPN 23198617
The following assemblies change from the 50psi check valve CPN 36321876 to the 75psi
pressure relief valve CPN 36037190:
The HP air schematic 2657202251 should be updated to 75psi with the correct part number
(36037190)
The LP air oil schematic 2658317841 should also be updated to 65psi instead of 50 psi.
PV 271 / 275 New Spindle Adjusting Nut CPN 57954422
New Cylinders are stronger on the fact to have thicker wall and
new hydraulic connector box.
PV 271 / 275 with Generator for Cold Weather
PV 271 / 275 with Generator for Cold Weather
PV 271 / 275 with Generator for Cold Weather
Item 21