Professional Documents
Culture Documents
1 – Grading Requirements
Sieve Designation
Standard, mm Alternate US Standard Mass Percent Passing
50 2” 100
25 1” 55 – 85
9.5 3/8” 40 – 75
0.075 No. 200 0 - 12
The fraction passing the 0.075 mm (No. 200) sieve shall not be greater
than 0.66 (two thirds) of the fraction passing the 0.425 mm (No. 40) sieve.
The fraction passing the 0.425 mm (No. 40) sieve shall have a liquid limit
not greater than 35 and plasticity index not greater than 12 as determined by
AASHTO T 89 and T 90, respectively.
The coarse portion, retained on a 2.00 mm (No. 10) sieve, shall have a
mass percent of wear not exceeding 50 by the Los Angeles Abrasion Tests as
determined by AASHTO T 96.
The material shall have a soaked CBR value of not less than 25% as
determined by AASHTO T 193. The CBR value shall be obtained at the
maximum dry density and determined by AASHTO T 180, Method D.
Table 201.1 – Grading Requirements
The fraction passing the 0.075 mm (No. 200) sieve shall not be greater
than 0.66 (two thirds) of the fraction passing the 0.425 mm (No. 40) sieve.
The fraction passing the 0.425 mm (No. 40) sieve shall have a liquid limit
not greater than 25 and plasticity index not greater than 6 as determined by
AASHTO T 89 and T 90, respectively.
Table 311.2 – Grading Requirement for Coarse Aggregate
63 2-1/2” 100
50 2” 100 95 – 100
37.5 1-1/2” 95 – 100 - 100
25 1” - 35 – 70 100 95 – 100
19.0 ¾” 35 – 70 - 100 95 – 100 -
12.5 ½” - 10 – 30 90 – 100 - 25 – 60
9.5 3/8” 10 – 30 - 40 – 70 20 – 55 -
4.75 No.4 0-5 0-5 0 – 15* 0 – 10* 0 – 10*
* The measured cement content shall be within plus (+) or minus (-) 2 mass
percent of the design cement content.