Professional Documents
Culture Documents
1.2. Relevant identified uses of the substance or mixture and uses advised against
1.2.1. Relevant identified uses
Main use category : Industrial use
Use of the substance/mixture : Metal Treatment, Cleaning Agent
United Kingdom National Poisons Information Service Penlan Road 0344 892 0111 Only for healthcare
(Cardiff Centre) CF64 2XX Llandough professionals
University Hospital Llandough
United Kingdom National Poisons Information Service Little France Crescent 0344 892 0111 Only for healthcare
(Edinburgh Centre) EH16 4SA Edinburgh professionals
Royal Infirmary of Edinburgh
United Kingdom Guy's & St Thomas' Poisons Unit Avonley Road +44 20 7188 7188
Medical Toxicology Unit, Guy's & St SE14 5ER London
Thomas' Hospital Trust
GHS05
Signal word (CLP) : Danger
Contains : Alkoxylated C10 Longchain Alcohol Polymer, phosphoric acid … %, orthophosphoric acid …
%
Hazard statements (CLP) : H314 - Causes severe skin burns and eye damage.
Precautionary statements (CLP) : P280 - Wear protective clothing, eye protection, face protection.
P303+P361+P353 - IF ON SKIN (or hair): Take off immediately all contaminated clothing.
Rinse skin with water .
P305+P351+P338 - IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing.
P308+P313 - IF exposed or concerned: Get medical advice/attention.
P405 - Store locked up.
P501 - Dispose of contents and container to an approved waste disposal plant.
3.1. Substances
Not applicable
3.2. Mixtures
phosphoric acid … %, orthophosphoric acid … % CAS-No.: 7664-38-2 ( 10 ≤C < 25) Skin Irrit. 2, H315
EC-No.: 231-633-2 ( 10 ≤C < 25) Eye Irrit. 2, H319
EC Index-No.: 015-011-00-6 ( 25 ≤C ≤ 100) Skin Corr. 1B, H314
REACH-no: 01-2119485924-
24-XXXX
Full text of H- and EUH-statements: see section 16
4.2. Most important symptoms and effects, both acute and delayed
Symptoms/effects after skin contact : Burns. Blisters.
Symptoms/effects after eye contact : Serious damage to eyes.
Symptoms/effects after ingestion : Burns.
4.3. Indication of any immediate medical attention and special treatment needed
Treat symptomatically. Show this safety data sheet to the doctor in attendance. It is recommended to have a safety shower close by. Eye bathing
equipment or running water should be available on the premises.
Other information : Dispose of materials or solid residues at an authorized site. Clean-up should be dealt with
only by qualified personnel who are familiar with the specific substance.
Eye protection:
Safety glasses. Wear a face shield
Hand protection:
Protective gloves. Acid-resistant protective gloves
Respiratory protection:
In case of insufficient ventilation, wear suitable respiratory equipment
10.1. Reactivity
The product is non-reactive under normal conditions of use, storage and transport.
Willowchem 61
LD50 oral rat > 2000 mg/kg Calculated
Skin corrosion/irritation : May produce skin irritation, blistering, ulcers, and deep scarring
pH: < 2
Serious eye damage/irritation : May cause permanent damage.
pH: < 2
Respiratory or skin sensitisation : Not classified
Germ cell mutagenicity : Not classified
Carcinogenicity : Not classified
Reproductive toxicity : Not classified
STOT-single exposure : Not classified
STOT-repeated exposure : Not classified
Aspiration hazard : Not classified
12.1. Toxicity
Ecology - general : Before neutralisation, the product may represent a danger to aquatic organisms.
Hazardous to the aquatic environment, short–term : Not classified
(acute)
Hazardous to the aquatic environment, long–term : Not classified
(chronic)
Not rapidly degradable
Willowchem 61
EC50 - Other aquatic organisms [1] > 100 mg/l Calculated (Daphnia Magna)
Willowchem 61
Persistence and degradability Mixtue of inorganic & organic components, therefore can not be classified as
biodegradable. The components are expectd to degrade and/or disassociate in water and
soil.
Willowchem 61
Bioaccumulative potential The product is not expected to bioaccumulate.
Willowchem 61
Additional information Not volatile. soluble in water
Willowchem 61
This substance/mixture does not meet the PBT criteria of REACH regulation, annex XIII
This substance/mixture does not meet the vPvB criteria of REACH regulation, annex XIII
14.1. UN number
UN 3264 UN 3264 UN 3264 UN 3264 UN 3264
UN 3264 CORROSIVE UN 3264 CORROSIVE UN 3264 Corrosive liquid, UN 3264 CORROSIVE UN 3264 CORROSIVE
LIQUID, ACIDIC, LIQUID, ACIDIC, acidic, inorganic, n.o.s. LIQUID, ACIDIC, LIQUID, ACIDIC,
INORGANIC, N.O.S. INORGANIC, N.O.S. (orthophosphoric acid), 8, INORGANIC, N.O.S. INORGANIC, N.O.S.
(orthophosphoric acid), 8, (orthophosphoric acid), 8, III (orthophosphoric acid), 8, (orthophosphoric acid), 8,
III, (E) III III III
Overland transport
Classification code (ADR) : C1
Special provisions (ADR) : 274
Limited quantities (ADR) : 5l
Excepted quantities (ADR) : E1
Packing instructions (ADR) : P001, IBC03, LP01, R001
Mixed packing provisions (ADR) : MP19
Portable tank and bulk container instructions (ADR) : T7
Portable tank and bulk container special provisions : TP1, TP28
(ADR)
Tank code (ADR) : L4BN
Tank special provisions (ADR) : TU42
Vehicle for tank carriage : AT
Transport category (ADR) : 3
Special provisions for carriage - Packages (ADR) : V12
Hazard identification number (Kemler No.) : 80
Orange plates :
Transport by sea
Special provisions (IMDG) : 223, 274
Limited quantities (IMDG) : 5L
Excepted quantities (IMDG) : E1
Packing instructions (IMDG) : P001, LP01
IBC packing instructions (IMDG) : IBC03
Tank instructions (IMDG) : T7
Tank special provisions (IMDG) : TP1, TP28
EmS-No. (Fire) : F-A
EmS-No. (Spillage) : S-B
Air transport
PCA Excepted quantities (IATA) : E1
PCA Limited quantities (IATA) : Y841
PCA limited quantity max net quantity (IATA) : 1L
PCA packing instructions (IATA) : 852
PCA max net quantity (IATA) : 5L
CAO packing instructions (IATA) : 856
CAO max net quantity (IATA) : 60L
Special provisions (IATA) : A3, A803
ERG code (IATA) : 8L
Rail transport
Classification code (RID) : C1
Special provisions (RID) : 274
Limited quantities (RID) : 5L
Excepted quantities (RID) : E1
Packing instructions (RID) : P001, IBC03, LP01, R001
Mixed packing provisions (RID) : MP19
Portable tank and bulk container instructions (RID) : T7
Portable tank and bulk container special provisions : TP1, TP28
(RID)
Tank codes for RID tanks (RID) : L4BN
Special provisions for RID tanks (RID) : TU42
Transport category (RID) : 3
Special provisions for carriage – Packages (RID) : W12
Colis express (express parcels) (RID) : CE8
Hazard identification number (RID) : 80
14.7. Transport in bulk according to Annex II of Marpol and the IBC Code
Not applicable
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
15.1.1. EU-Regulations
Germany
Employment restrictions : Observe restrictions according Act on the Protection of Working Mothers (MuSchG).
Observe restrictions according Act on the Protection of Young People in Employment
(JArbSchG).
Water hazard class (WGK) : WGK 3, Highly hazardous to water (Classification according to AwSV, Annex 1).
Hazardous Incident Ordinance (12. BImSchV) : Is not subject of the Hazardous Incident Ordinance (12. BImSchV)
Netherlands
SZW-lijst van kankerverwekkende stoffen : None of the components are listed
SZW-lijst van mutagene stoffen : None of the components are listed
SZW-lijst van reprotoxische stoffen – Borstvoeding : None of the components are listed
SZW-lijst van reprotoxische stoffen – : None of the components are listed
Vruchtbaarheid
SZW-lijst van reprotoxische stoffen – Ontwikkeling : None of the components are listed
Denmark
Classification remarks : Emergency management guidelines for the storage of flammable liquids must be followed
Danish National Regulations : Young people below the age of 18 years are not allowed to use the product
Switzerland
Storage class (LK) : LK 8 - Corrosive materials
ADR European Agreement concerning the International Carriage of Dangerous Goods by Road
EN European Standard
This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental
requirements only. It should not therefore be construed as guaranteeing any specific property of the product.