Professional Documents
Culture Documents
1.2. Relevant identified uses of the substance or mixture and uses advised against
1.2.1. Relevant identified uses
Main use category : Industrial use,Professional use
Industrial/Professional use spec : For professional use only
Industrial
Use of the substance/mixture : Lubricants, Greases and Release Products
Manufacturer
ROCOL a division of ITW Ltd
Rocol House Wakefield Rd, Swillington
LS26 8BS Leeds – West Yorkshire
United Kingdom
T +44 (0)113 232 2600
customer.service@rocol.com - www.rocol.com
GHS08
Signal word (CLP) : Danger
Contains : HYDROCARBONS, C11-C14, N-ALKANES, ISOALKANES, CYCLICS, <2% AROMATICS
Hazard statements (CLP) : H304 - May be fatal if swallowed and enters airways.
Precautionary statements (CLP) : P261 - Avoid breathing dust/fume/gas/mist/vapours/spray.
P280 - Wear protective clothing, eye protection, face protection.
P301+P310+P331 - IF SWALLOWED: Immediately call a POISON CENTER or doctor. Do
NOT induce vomiting.
P333+P313 - If skin irritation or rash occurs: Get medical advice/attention.
P361+P364 - Take off immediately all contaminated clothing and wash it before reuse.
EUH-statements : EUH066 - Repeated exposure may cause skin dryness or cracking.
EUH208 - Contains BENZENESULFONIC ACID C10-16 CALCIUM SALT(68584-23-6),
BENZENESULFONIC ACID, MONO-C16-24-ALKYL DERIVS, CALCIUM SALTS(70024-69-
0), SULFONIC ACIDS, PETROLEUM, CALCIUM SALTS(61789-86-4). May produce an
allergic reaction.
The mixture does not contain substance(s) included in the list established in accordance with Article 59(1) of REACH for having endocrine disrupting
properties, or is not identified as having endocrine disrupting properties in accordance with the criteria set out in Commission Delegated Regulation
(EU) 2017/2100 or Commission Regulation (EU) 2018/605 at a concentration equal to or greater than 0,1 %
3.1. Substances
Not applicable
3.2. Mixtures
BENZENESULFONIC ACID C10-16 CALCIUM SALT CAS-No.: 68584-23-6 0.1 – 1 Skin Sens. 1B, H317
EC-No.: 271-529-4
REACH-no: 01-2119492627-
25
BENZENESULFONIC ACID, MONO-C16-24-ALKYL CAS-No.: 70024-69-0 0.1 – 1 Skin Sens. 1B, H317
DERIVS., CALCIUM SALTS EC-No.: 274-263-7
REACH-no: 01-2119492616-
28
SULFONIC ACIDS, PETROLEUM, CALCIUM SALTS CAS-No.: 61789-86-4 <1 Skin Sens. 1, H317
EC-No.: 263-093-9
REACH-no: 01-2119488992-
18
Full text of H- and EUH-statements: see section 16
First-aid measures after skin contact : Remove affected clothing and wash all exposed skin area with mild soap and water,
followed by warm water rinse.
First-aid measures after eye contact : Rinse immediately with plenty of water. Obtain medical attention if pain, blinking or redness
persists.
First-aid measures after ingestion : Rinse mouth. Do NOT induce vomiting. Immediately call a POISON CENTER/doctor.
4.2. Most important symptoms and effects, both acute and delayed
No additional information available
4.3. Indication of any immediate medical attention and special treatment needed
No additional information available
Eye protection:
Chemical goggles or safety glasses
Hand protection:
Wear protective gloves. Nitrile rubber gloves
Respiratory protection:
Not required for normal conditions of use. [In case of inadequate ventilation] wear respiratory protection. Wear a respirator conforming to EN140
with Type A filter or better
Other information:
Do not eat, drink or smoke during use.
10.1. Reactivity
No additional information available
LD50 dermal rabbit > 2000 mg/kg bodyweight Animal: rabbit, Guideline: EPA OTS 798.1100 (Acute Dermal
Toxicity), Guideline: OECD Guideline 402 (Acute Dermal Toxicity)
LC50 Inhalation - Rat > 5.28 mg/l air Animal: rat, Guideline: OECD Guideline 403 (Acute Inhalation Toxicity),
95% CL: 0,42 -
LD50 dermal rabbit > 4000 mg/kg bodyweight Animal: rabbit, Guideline: other:40 CFR, Section 163.81-2,
Federal Register, August 22, 1978
LC50 Inhalation - Rat > 1.9 mg/l air Animal: rat, Guideline: EPA OPP 81-3 (Acute inhalation toxicity)
LD50 dermal rabbit > 4000 mg/kg bodyweight Animal: rabbit, Guideline: other:40 CFR, Section 163.81-2,
Federal Register, August 22, 1978
LC50 Inhalation - Rat > 1.9 mg/l air Animal: rat, Guideline: EPA OPP 81-3 (Acute inhalation toxicity)
Skin corrosion/irritation : Not classified
Additional information : Based on available data, the classification criteria are not met
Serious eye damage/irritation : Not classified
Additional information : Based on available data, the classification criteria are not met
Respiratory or skin sensitisation : Not classified
Additional information : Based on available data, the classification criteria are not met
Germ cell mutagenicity : Not classified
Additional information : Based on available data, the classification criteria are not met
Carcinogenicity : Not classified
Additional information : Based on available data, the classification criteria are not met
Reproductive toxicity : Not classified
Additional information : Based on available data, the classification criteria are not met
NOAEL (dermal, rat/rabbit, 90 days) > 1000 mg/kg bodyweight Animal: rat, Guideline: OECD Guideline 410 (Repeated Dose
Dermal Toxicity: 21/28-Day Study)
NOAEL (dermal, rat/rabbit, 90 days) > 1000 mg/kg bodyweight Animal: rat, Guideline: OECD Guideline 410 (Repeated Dose
Dermal Toxicity: 21/28-Day Study)
Aspiration hazard : May be fatal if swallowed and enters airways.
PRETON R-303 P
Viscosity, kinematic < 5 mm²/s
Hydrocarbon Yes
Hydrocarbon Yes
12.1. Toxicity
Hazardous to the aquatic environment, short–term : Not classified
(acute)
Hazardous to the aquatic environment, long–term : Not classified
(chronic)
EC50 72h - Algae [1] > 1000 mg/l Test organisms (species): Pseudokirchneriella subcapitata (previous names:
Raphidocelis subcapitata, Selenastrum capricornutum)
EC50 96h - Algae [1] > 1000 mg/l Test organisms (species): Pseudokirchneriella subcapitata (previous names:
Raphidocelis subcapitata, Selenastrum capricornutum)
EC50 72h - Algae [1] > 1000 mg/l Test organisms (species): Pseudokirchneriella subcapitata (previous names:
Raphidocelis subcapitata, Selenastrum capricornutum)
EC50 96h - Algae [1] > 1000 mg/l Test organisms (species): Pseudokirchneriella subcapitata (previous names:
Raphidocelis subcapitata, Selenastrum capricornutum)
PRETON R-303 P
Persistence and degradability Not established.
PRETON R-303 P
Bioaccumulative potential Not established.
Overland transport
Not regulated
Transport by sea
Not regulated
Air transport
Not regulated
Rail transport
Not regulated
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
15.1.1. EU-Regulations
Indication of changes
Section Changed item Change Comments
Data sources : REGULATION (EC) No 1272/2008 OF THE EUROPEAN PARLIAMENT AND OF THE
COUNCIL of 16 December 2008 on classification, labelling and packaging of substances
and mixtures, amending and repealing Directives 67/548/EEC and 1999/45/EC, and
amending Regulation (EC) No 1907/2006.
Other information : None.
EUH208 Contains BENZENESULFONIC ACID C10-16 CALCIUM SALT(68584-23-6), BENZENESULFONIC ACID, MONO-
C16-24-ALKYL DERIVS, CALCIUM SALTS(70024-69-0), SULFONIC ACIDS, PETROLEUM, CALCIUM
SALTS(61789-86-4). May produce an allergic reaction.
This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental
requirements only. It should not therefore be construed as guaranteeing any specific property of the product.