Professional Documents
Culture Documents
: 6642331
8. Fit the intermediate gear as instructed in the work description Fitting the intermediate
gear.
9. Ensure that the markings on the camshaft gear point towards the centre of the intermediate
gear.
10. Fit the camshaft gear and tighten the screws.
11. Fit the flywheel housing as described in the work description Fitting the flywheel
housing.
12. Fit the flywheel as described in the work description Fitting the flywheel.
13. Refit all components that were removed from the engine side: High pressure pump, fuel
filter housing with holder, engine control unit and cooling coil for AC compressor (if
fitted).
14. Remove all old sealing compound on the cylinder block and the sealing surface on the
front camshaft cover. Clean off any oil and grease from the sealing surfaces using an
alcohol based detergent.
Important!
Important!
Important!
2011-08-23 ?Scania CV 9 of 10