Professional Documents
Culture Documents
Question 1
The tied column of Figure has been approximately sized to the dimensions 12
in. x 15 in. It is to be used in a frame braced against sidesway. The column is
bent in single curvature about its y-axis and has an LU of 16 ft. If k = 0.83, fy =
60,000 psi, and f ' c = 4000 psi, determine the reinforcing required. Consider
only bending in the plane of the frame. Note also that the unfactored dead axial
load P D is 30 k, and concrete is normal weight.
Question 2
The beam as in Figure has a simple span of 20 ft and supports a dead load
including its own weight of 1 k/ft and a live load of 0.7 k/ft. f ' c = 3000 psi.
Calculate the instantaneous deflection for D + L.
Question 3
Q2: The cantilever beam shown in the figure below carries an unfactored dead
load of 11.5 kN/m and an un factored live load of 6 kN/m. The beam is located
at a typical floor and supports walls that are not likely to be damaged by
deflection. It is required to calculate the immediate and the long-term deflection
which Time-Dependent Factor is 2. The deflection must not exceed L/ 480.
f ' c =35 , n = 10 , no need to check minimum depth.