Professional Documents
Culture Documents
1 | Page
DA 42 QUESTION BANK
d. 254 degrees F
10. The minimum and maximum fuel pressure of DA42 is:
a. 17psi,34psi
b. 15psi,30psi
c. 12psi,30psi
d. 14psi,35psi
11. Max continuous horsepower for DA42 is:
a. 180 hp
b. 160 hp
c. 200 hp
d. 175 hp
12. DA42 propeller diameter is:
a. 70.20 in
b. 72.50 in
c. 70.02 in
d. 72.05 in
13. DA42 variable pitch propeller is controlled by:
a. Air Pressure
b. Oil Pressure
c. Nitrogen Pressure
d. Foot Pressure
14. How many blades does the DA42 propeller engine have:
a. 1 blades
b. 2 blades
c. 3 blades
d. 4 blades
15. What is the wingspan of the DA42?
a. 14.32 m
b. 13.42 m
c. 12.34 m
d. 11.54 m
16. What is the wing area of the DA42?
a. 12.69 m²
b. 13.96 m²
c. 14.69 m²
d. 16.29 m²
2 | Page
DA 42 QUESTION BANK
c. 11.06
d. 12.05
19. Angle of incidence of horizontal tail of DA42 is:
a. -1.2 degrees
b. -1.1 degrees
c. 1.2 degrees
d. 1.1 degrees
20. DA42 rudder area is:
a. 2.43 m2
b. 0.24 m2
c. 0.78 m2
d. 7.8 m2
21. Leading edge sweep of the DA42 wing is:
a. 1 degree
b. 2 degrees
c. 3 degrees
d. 0 degrees
22. What is the max speed that the landing gear wheels can be
subjected to:
a. 110 mph
b. 120 mph
c. 178 mph
d. 90 mph
23. What is the wheel base of the DA42?
a. 1.535m
b. 1.735m
c. 2.654m
d. 1.365m
24. What is Va for the DA42 up to 1542kgs
a. 120 KIAS
b. 126 KIAS
c. 123 KIAS
d. 143 KIAS
3 | Page
DA 42 QUESTION BANK
27. Minimum Airspeed for take-off climb with Flaps up(best rate
of climb speed: Vy)
a. 70 KIAS
b. 68 KIAS
c. 90 KIAS
d. 88 KIAS
28. Minimum Final Approach Speed with Landing Flaps
a. 70 KIAS
b. 68 KIAS
c. 90 KIAS
d. 85 KIAS
29. Intentional one engine inoperative speed ( Vsse) for DA42
a. 80 KIAS
b. 68 KIAS
c. 90 KIAS
d. 88 KIAS
30. Minimum Go Around Speed for DA42 is
a. 80 KIAS
b. 85 KIAS
c. 90 KIAS
d. 88 KIAS
31. What is the maximum landing gear extension speed of DA42
a. 195 KIAS
b. 190 KIAS
c. 194 KIAS
d. 184 KIAS
32. What is the maximum landing gear retraction speed of DA42
a. 156 KIAS
b. 182 KIAS
c. 194 KIAS
d. 164 KIAS
4 | Page
DA 42 QUESTION BANK
c. 90 KIAS
d. 80 KIAS
36. What is VNO Max. structural cruising speed of DA42
a. 160 KIAS
b. 155 KIAS
c. 149 KIAS
d. 130 KIAS
37. What is the VNE Never exceed speed in smooth air of DA42
a. 179 KIAS
b. 189 KIAS
c. 194 KIAS
d. 210 KIAS
38. What is the White band Operating range with flaps fully
extended of DA42
a. 57 - 111 KIAS
b. 58-112 KIAS
c. 60-120 KIAS
d. 55-110 KIAS
39. What is the Green band Normal operating range of DA42
a. 60-112 KIAS
b. 64 - 155 KIAS
c. 66-125 KIAS
d. 70-113 KIAS
40. What is the Yellow band Caution’ range - “Only in smooth
air” of DA42
a. 160-194 KIAS
b. 155 - 194 KIAS
c. 170-200 KIAS
d. 165-190 KIAS
41. What is the Blue band Best rate of climb speed, single
engine of the DA42
a. 80 KIAS
b. 100 KIAS
c. 90 KIAS
d. 70 KIAS
42. What is the Red band Minimum control speed, single engine of
DA42
a. 55 KIAS
b. 60 KIAS
c. 65 KIAS
d. 70 KIAS
43. What is the stalling speed with flaps fully down and gear
down (Vso) for 1785 Kg weight in level flight.
a. 55 Kts
5 | Page
DA 42 QUESTION BANK
b. 56 Kts
c. 57 Kts
d. 58 Kts
44. What is the normal operating range for manifold pressure for
DA42
a. 15-30 inHg
b. 12-40 inHg
c. 20-40 inHg
d. 13-31 inHg
45. What is the normal operating range for the Propeller RPM for
DA42
a. 1000-3000 RPM
b. 500-3000 RPM
c. 500-2700 RPM
d. 800-3500 RPM
46. The Fuel Quantity Indicator range of DA42 aircraft is
a. 1-25 Gal
b. 1-40 Gal
c. 1-30 Gal
d. 1-45 Gal
47. The Positive Maneuvering Load Factor at VA is
a. 3.8
b. 2.0
c. 4.5
d. -1.2
48. The Positive Maneuvering Load Factor at VNE is
a. 3.8
b. 2.8
c. 2.0
d. 4.8
49. The Positive Maneuvering Load Factor with Flaps down is
a. 3.8
b. 2.8
c. 2.0
d. 4.8
50. The Negative Maneuvering Load Factor at V A is
a. -1.78
b. -2.8
c. -2.0
d. -1.52
51. The permitted negative Load Factor at VNE is
a. -1.8
b. -2
c. -2.5
d. 0
6 | Page
DA 42 QUESTION BANK
52. The Maximum Operating altitude of DA42 is
a. 10000
b. 19500
c. 18000
d. 14500
53. The minimum operating crew number for DA42 is
a. 2
b. 1
c. 3
d. 4
54. Maximum number of occupants of DA42 is
a. 5
b. 4
c. 3
d. 2
55. The Total usable fuel quantity of the main fuel tanks is of
DA42 in gallons is
a. 26x2
b. 25x2
c. 20x2
d. 15x2
56. The Total fuel capacity of the main tanks of DA42 in gallons
is
a. 26x2
b. 20x2
c. 23x2
d. 21x2
57. The maximum permissible difference in fuel quantities of the
left and right main fuel tanks of DA42 in gallons is
a. 3
b. 4
c. 5
d. 7
58. The Maximum Take-off Weight of DA42 is
a. 3935
b. 3500
c. 3400
d. 4500
59. The Datum plane is located at a distance of ……….from the
wing root,
a. 2.193m
b. 2.196m
c. 2.195m
d. 2.192m
60. The red arc of voltage starts at
7 | Page
DA 42 QUESTION BANK
a. 24 V
b. 25V
c. 23 V
d. 28.1 V
61. The Maximum Landing Weight of DA42
a. 3748
b. 4000
c. 3935
d. 3557
62. Restarting the engine is possible from any safe speed
till……………
a. 190 Kts
b. 194 kts
c. 195 kts
d. 192 kts
63. Oil pressure should register within ……sec after start.
a. 20 Sec
b. 25 Sec
c. 15 Sec
d. 10 sec
64. Landing gear unsafe light should not be on for more than ......... sec.
a. 15 sec
b. 20 sec
c. 10 sec
d. 25 sec
65. If oil temperature indication is high and CHT and EGT is normal
then it is a
a. An oil temperature indication fault
b. An oil temperature probe fault
c. An actual oil pressure failure
d. none of the above
66. In case of strong winds, wind shear and turbulence the airspeed
on approach should be:
a. Higher
b. Lower
c.Correct
d. none of the above
67. Manual extension of landing gear can take ......... sec.
a. 15 sec
b.20 sec
c.25 sec
d.30 sec
68. Yawing and pitching can be done to assist the landing gear to
lock down in case of manual lowering of the undercarriage. The
speed should be reduced to:
8 | Page
DA 42 QUESTION BANK
a. 100 kts
b. 115 kts
c. 120 kts
d. 110 kts
69. If alternator fails then the battery power will last ……minutes.
a. 25 minutes
b. 30 minutes
c. 35 minutes
d. 40 minutes
70 The maximum speed at which canopy can be opened in flight in
case of smoke in cockpit is:
a. 100 kts
b. 110 kts
c. 115 kts
d. 120 kts
71. The electrically driven hydraulic pump comes on for
…………..seconds when the electrical master is put on.
a. 5-10 sec
b. 5-20 sec
c. 10-20 sec
d. 10-30 sec
72. Minimum oil for IFR flight is ............. quarts.
a. 4 Quarts
b. 5 Quarts
c. 6 Quarts
d. 8 quarts
9 | Page
DA 42 QUESTION BANK
b. 25 minutes
c. 30 minutes
d. 35 minutes
77. To check cross feed the engines should be run for a minimum of
……..secs.
a. 20 seconds
b. 25 seconds
c. 30 seconds
d. 35 seconds
78. In a magneto check the maximum difference between Lt and Rt
magneto RPM can be
a. 100 RPM
b. 75 RPM
c. 175 RPM
d. 50 RPM
79. The maximum RPM drop when switching of one magneto is ……..
a. 100 RPM
b. 75 RPM
c. 175 RPM
d. 50 RPM
80. The maximum RPM drop when doing feathering check is ……..
a. 100 RPM
b. 75 RPM
c. 175 RPM
d. 300 RPM
10 | P a g e
DA 42 QUESTION BANK
c. 150-435 Deg F
d. 100-435 Deg F
85. CHT should not exceed ………deg F in fast cruise.
a. 400 Deg F
b. 425 Deg F
c. 435 Deg F
d. 445 Deg F
86. Oil temperature should be between ……..to …………Deg F for
continuous operation.
a. 160- 220 Deg F
b. 165- 220 Deg F
c. 150- 200 Deg F
d. 155- 200 Deg F
87. To get best power mixture the EGT should be …………deg F lower than
best economy.
a. 75 Deg F lower
b. 90 Deg F lower
c. 100 Deg F lower
d. 110 Deg F lower
88. When reducing power then the CHT should not drop by more than
……….Deg F per minute.
a. 25 Deg F
b. 30 Deg F
c. 40 Deg F
d. 50 Deg F
11 | P a g e
DA 42 QUESTION BANK
a. 10 Kts
b. 12 Kts
c. 14 Kts
d. 15 Kts
93. An upslope of 2 % increases take off distance by ........... %
a. 10 %
b. 12 %
c. 15 %
d. 17 %
94. For each 4 Knots of headwind decrease takeoff distance by............ %
a. 2 %
b. 3 %
c. 4 %
d. 5 %
95. For each 2 Knots of tailwind increase takeoff distance by............ %
a. 2%
b. 3%
c. 4%
d. 5%
96. Unusable fuel in main tanks is ............... liters.
a. 6 Liters
b. 7 Liters
c. 7.6 Liters
d. 8 Liters
12 | P a g e
DA 42 QUESTION BANK
c. 28 V
d. 26 V
13 | P a g e
DA 42 QUESTION BANK
ANSWER SHEET
1 A
2 B
3 A
4 A
5 A
6 C
7 B
8 B
9 B
10 D
11 B
12 D
13 B
14 C
15 B
16 D
17 A
18 C
19 B
20 C
21 A
22 B
23 B
24 A
25 C
26 C
27 C
28 D
29 A
30 B
31 C
32 A
33 C
34 B
35 C
B
14 | P a g e
DA 42 QUESTION BANK
36
37 C
38 A
39 B
40 B
41 C
42 C
43 C
44 D
45 C
46 A
47 A
48 A
49 C
50 D
51 D
52 C
53 B
54 B
55 B
56 A
57 C
58 A
59 B
60 A
61 A
62 B
63 C
64 B
65 A
66 A
67 B
68 D
69 B
70 D
B
15 | P a g e
DA 42 QUESTION BANK
71
72 C
73 A
74 D
75 A
76 C
77 C
78 D
79 C
80 D
81 C
82 A
83 C
84 B
85 C
86 B
87 C
88 D
89 B
90 C
91 A
92 C
93 A
94 B
95 D
96 C
97 C
98 A
99 B
100 C
16 | P a g e
DA 42 QUESTION BANK
17 | P a g e