Professional Documents
Culture Documents
1|Page
DA 42 QUESTION BANK
2|Page
DA 42 QUESTION BANK
3|Page
DA 42 QUESTION BANK
4|Page
DA 42 QUESTION BANK
5|Page
DA 42 QUESTION BANK
41. What is the Blue band Best rate of climb speed, single engine of the DA42
a. 80 KIAS
b. 100 KIAS
c. 90 KIAS
d. 70 KIAS
42. What is the Red band Minimum control speed, single engine of DA42
a. 55 KIAS
b. 60 KIAS
c. 65 KIAS
d. 70 KIAS
43. What is the stalling speed with flaps fully down and gear down (Vso) for 1785 Kg weight in level
flight.
a. 55 Kts
b. 56 Kts
c. 57 Kts
d. 58 Kts
44. What is the normal operating range for manifold pressure for DA42
a. 15-30 inHg
b. 12-40 inHg
c. 20-40 inHg
d. 13-31 inHg
45. What is the normal operating range for the Propeller RPM for DA42
a. 1000-3000 RPM
b. 500-3000 RPM
c. 500-2700 RPM
d. 800-3500 RPM
46. The Fuel Quantity Indicator range of DA42 aircraft is
a. 1-25 Gal
b. 1-40 Gal
c. 1-30 Gal
d. 1-45 Gal
47. The Positive Maneuvering Load Factor at VA is
a. 3.8
b. 2.0
c. 4.5
d. -1.2
48. The Positive Maneuvering Load Factor at VNE is
a. 3.8
b. 2.8
c. 2.0
d. 4.8
6|Page
DA 42 QUESTION BANK
7|Page
DA 42 QUESTION BANK
57. The maximum permissible difference in fuel quantities of the left and right main fuel tanks of
DA42 in gallons is
a. 3
b. 4
c. 5
d. 7
58. The Maximum Take-off Weight of DA42 is
a. 3935
b. 3500
c. 3400
d. 4500
59. The Datum plane is located at a distance of ……….from the wing root,
a. 2.193m
b. 2.196m
c. 2.195m
d. 2.192m
60. The red arc of voltage starts at
a. 24 V
b. 25V
c. 23 V
d. 28.1 V
61. The Maximum Landing Weight of DA42
a. 3748
b. 4000
c. 3935
d. 3557
62. Restarting the engine is possible from any safe speed till……………
a. 190 Kts
b. 194 kts
c. 195 kts
d. 192 kts
63. Oil pressure should register within ……sec after start.
a. 20 Sec
b. 25 Sec
c. 15 Sec
d. 10 sec
64. Landing gear unsafe light should not be on for more than …..sec.
a. 15 sec
b. 20 sec
c. 10 sec
d. 25 sec
8|Page
DA 42 QUESTION BANK
65. If oil temperature indication is high and CHT and EGT is normal then it is a
a. An oil temperature indication fault
b. An oil temperature probe fault
c. An actual oil pressure failure
d. none of the above
66. In case of strong winds, wind shear and turbulence the airspeed on approach should be:
a. Higher
b. Lower
c. Correct
d. none of the above
67. Manual extension of landing gear can take …….sec.
a. 15 sec
b. 20 sec
c. 25 sec
d. 30 sec
68. Yawing and pitching can be done to assist the landing gear to lock down in case of manual
lowering of the undercarriage. The speed should be reduced to:
a. 100 kts
b. 115 kts
c. 120 kts
d. 110 kts
69. If alternator fails then the battery power will last ……minutes.
a. 25 minutes
b. 30 minutes
c. 35 minutes
d. 40 minutes
70 The maximum speed at which canopy can be opened in flight in case of smoke in cockpit is:
a. 100 kts
b. 110 kts
c. 115 kts
d. 120 kts
71. The electrically driven hydraulic pump comes on for …………..seconds when the electrical
master is put on.
a. 5-10 sec
b. 5-20 sec
c. 10-20 sec
d. 10-30 sec
72. Minimum oil for IFR flight is ……………quarts.
a. 4 Quarts
b. 5 Quarts
c. 6 Quarts
9|Page
DA 42 QUESTION BANK
d. 8 quarts
10 | P a g e
DA 42 QUESTION BANK
d. 300 RPM
11 | P a g e
DA 42 QUESTION BANK
89. After landing keep RPM between ……….to …………for temperatures to stabilize.
a. 1000-1200 RPM
b. 800-1200 RPM
c. 900-1200 RPM
d. 1100-1200 RPM
90. The maximum continuous HP is not to exceed.
a. 140 BHP
b. 150 BHP
c. 160 BHP
d. 170 BHP
91. The staling speed with flaps up and landing gear up is …..kts at a weight of 1785 Kgs is…
a. 64 Kts
b. 63 Kts
c. 62 Kts
d. 61 Kts
92. The Maximum demonstrated crosswind is …………….kts.
a. 10 Kts
b. 12 Kts
c. 14 Kts
d. 15 Kts
93. An upslope of 2 % increases take off distance by ……..%
a. 10 %
b. 12 %
c. 15 %
d. 17 %
94. For each 4 Knots of headwind decrease takeoff distance by …………%
a. 2 %
b. 3 %
c. 4 %
d. 5 %
95. For each 2 Knots of tailwind increase takeoff distance by …………%
a. 2%
b. 3%
c. 4%
d. 5%
96. Unusable fuel in main tanks is …………… liters.
a. 6 Liters
b. 7 Liters
c. 7.6 Liters
12 | P a g e
DA 42 QUESTION BANK
d. 8 Liters
97. The CO alert is calibrated to provide visual alert within ……minutes or less.
a. 3 Minutes
b. 4 Minutes
c. 5 Minutes
d. 6 Minutes
98. Unusable fuel in auxiliary tanks is …………..liters.
a. 3.8 liters
b. 4 liters
c. 4.2 liters
d. 4.5 liters
99. If any one throttle is below …………….MAP with the gear up the warning horn sounds.
a. 13”
b. 14”
c. 15”
d. 16”
100. The DA 42 has a …………V DC system.
a. 24 V
b. 32 V
c. 28 V
d. 26 V
13 | P a g e
DA 42 QUESTION BANK
ANSWER SHEET
1 A 36 B 71 B
2 B 37 C 72 C
3 A 38 A 73 A
4 A 39 B 74 D
5 A 40 B 75 A
6 C 41 C 76 C
7 B 42 C 77 C
8 B 43 C 78 D
9 B 44 D 79 C
10 D 45 C 80 D
11 B 46 A 81 C
12 D 47 A 82 A
13 B 48 A 83 C
14 C 49 C 84 B
15 B 50 D 85 C
16 D 51 D 86 B
17 A 52 C 87 C
18 C 53 B 88 D
19 B 54 B 89 B
20 C 55 B 90 C
21 A 56 A 91 A
22 B 57 C 92 C
23 B 58 A 93 A
24 A 59 B 94 B
25 C 60 A 95 D
26 C 61 A 96 C
27 C 62 B 97 C
28 D 63 C 98 A
29 A 64 B 99 B
30 B 65 A 100 C
31 C 66 A
32 A 67 B
33 C 68 D
34 B 69 B
35 C 70 D
14 | P a g e
DA 42 QUESTION BANK
15 | P a g e