All of the following knife edges will fit all models of Epsilon
extensometers that use knife edges. The exceptions are high
temperature units that use ceramic rods, specialty extensometers
that require conical point contacts, asphalt extensometers,
clip-on gages, and deflectometers.
Standard Knife Edges Three-Point Contact
PART NO. 350210-01 Knife Edges Produced from hardened PART NO. 354299 tool steel, these knife edges These knife edges were designed for are used for a wide range use on flat specimens. They ensure of applications, and can be used on both round stable contact on flat test samples and rectangular shaped specimens. These are the due to 3-point contact. STRAIGHT VEE CONICAL standard knife edges supplied with most Epsilon CHISEL CHISEL CHISEL extensometers.
Dual Bevel Knife Edges
PART NO. 350210V2-01 Produced from high toughness tool steel. These knife edges Extended Knife Edges are used in applications PART NO. 350210EXT-01 where the standard knife Knife edges for applications where edges may experience excessive chipping, such as the additional length is required, on very hard metals. They are also ideal for high such as where the grips are very modulus composites. The dual bevel design and close together. Longer lengths are available on special Available Rod Tip Styles tougher material of construction provides a greater order. resistance to damage during testing. These knife edges are also recommended for biomedical testing Specify rod tip style desired. (especially bone) where stability of the contact point Straight chisel tips are the most versatile, since can be compromised due to the softness of the test Rounded Knife Edges they can be used with round or flat specimens. specimen. The dual bevel edge prevents slight output PART NO. 350210-BLUNT shifts on the sample that can result from the standard Knife edges designed for use on knife edges biting into the sample. transverse extensometers and applications where blunt edges are Ceramic Knife Edges required. These are primarily used PART NO. 350210C2-01 on transverse or diametral extensometers, such as the These knife edges are typically 3575, 3575AVG and 3675. used in low cycle fatigue applications on hard metals where metallic knife edges would likely experience undue wear. They are also used on Vee Knife Edges the submersible Model 4030 extensometer to prevent PART NO. 9903-01-01 galvanic corrosion between the extensometer and the Designed for use on round test specimen. specimens. Due to the contact point variation that can occur between Hardened Stainless Steel specimens of different diameters, PART NO. 350210-02 units with these knife edges must be These knife edges are designed calibrated with posts of equal diameter. On extenso to be used in environments meters with longer arms, errors created by this where additional strength variation are not so pronounced, but on units with and corrosion resistance is shorter arms lengths, this must be taken into consid required. Primary applications eration. The primary advantage is self-centering on the are in biomedical testing where test sample. the knife edges may be exposed to saline solutions. 100100