Professional Documents
Culture Documents
100H Inspection Tables
100H Inspection Tables
DO A DI FOR DAMAGE, CONDITION AND PLAY (NO REMOVAL REQUIRED) (AXIAL PLAY CHECK ONLY) (MAXIMUM
PLAY ALLOWED: 0.25 MM -0.0099 IN) . REFER TO: 39-A-62-22-00-00A-31AA-A
62- ROTATING CONTROLS INSTALLATION -PITCH CHANGE LINK ASSEMBLY SPHERICAL BEARINGS:
DO A DI FOR CONDITION, DAMAGE AND PLAY (REMOVAL OF PITCH CHANGE LINK ASSEMBLIES REQUIRED) (AXIAL
64- ROTATING CONTROLS INSTALLATION -PITCH CHANGE LINK ASSEMBLY SPHERICAL BEARINGS
DO A DI FOR CONDITION, DAMAGE AND PLAY (REMOVAL OF PITCH CHANGE LINK ASSEMBLIES REQUIRED) (AXIAL PLAY CHEC
Make sure that the measured distance Y is less than 26.90 mm (1.06 in).
Make sure that the measured distance X is more than 24.35 mm (0.96 in).
If the distances that you found are not in the given limits, replace the anti-rotation block (3) with a new item.
Refer to 39-A-62-22-07-00A-520A-A and 39-A-62-22-07-00A-720A-A. and record the details in below Table.
62-50
MAIN ROTOR DAMPER SPHERICAL BEARINGS
DO A DI FOR ALIGNMENT OF SLIPPAGE MARKS AND FOR SEALANT INTEGRITY ON THE STAKING AND
CERAMIC COATING DAMAGE OF EYE END ASSY AND BODY END ASSY SPHERICAL BEARINGS. REFER TO:
39- A-62-22-02-01A-31AA-A. NOTE: TASKS APPLICABLE ONLY TO MAIN ROTOR DAMPER P/N
3G6220V01353.
If you find that the bearing (3) has one or more defective conditions, replace the rod end (2). Refer to
data module 39-A-62-22-02-01A-921A-B.
If you find that the bearing (5) has one or more defective conditions, replace the lag damper (1). Refer to
data modules 39-A-62-22-02-00A-520A-A and 39-A-62-22-02-00A-720A-A.
If Lag Damper replaced If Damper rod end replaced
MR Damper Rectification WS
SN New PN New SN New PN New SN Ref
(if replaced):
HHT-100 Hours Mandatory Inspection
If the value is higher than 30.0 Nm (265.5 lb in) for Damper rod end, replace the damper rod end (see AMP DM n°
39-A-62-22-02-01A-921A-B). Record the details of defective part in below Table.
MR Torque If the Torque value recorded is higher than 30.0 Nm
Damper SN Value Damper rod end replaced
………………… Yes ☐ No ☐
………………… Yes ☐ No ☐
………………… Yes ☐ No ☐
………………… Yes ☐ No ☐
………………… Yes ☐ No ☐