This checklist / procedure manual is for flight simulator use APU Master Switch (OH) START only. This document is based on the Just Flight 146 Monitor APU RPM & TGT rise. Professional MSFS manual with added information of original APU AIR (OH) ON checklists. PACK 1 or 2 (OH) ON Use pack 1 on an “odd” day and pack 2 on an (CPT) Captain Panel “even” day. (CP) Centre Panel (FO) First Officer Panel INITIAL PREFLIGHT PROCEDURE (CC) Centre Console Cockpit Lights AS REQ. (OH) Overhead Panel MWS Control (CP) PUSH (LSP) Left Side Panel (CPT) Verify MWS annunciators illuminated + audible (RSP) Right Side Panel (FO) chimes. (TMS) Thrust Modulation System Panel MWS Control (CP) PULL (GS) Glare Shield Set to the middle position (not illuminated). abcdefg Most important for a quick start Ground Tests (OH) PERFORM abcdefg Gameplay / EFB / UI DC PUMP (OH) ON Check for a rise in YELLOW system hydraulic pressure. DC PUMP (OH) OFF SPECIFICATIONS / LIMITATIONS AC PUMP (OH) ON Variant -100 -200 -300 Check for a rise in YELLOW system hydraulic Max. Takeoff Weight (KG) 38.102 42.184 44.184 pressure. Max. Landing Weight (KG) 35.153 36.741 37.648 PTU (OH) ON Service Ceiling (ft) 35.000 Check for a rise in GREEN system hydraulic Range (max. payload) (NM) 935 1.176 1.090 pressure. Takeoff Roll (ft) 4.000 4.950 4.950 AC PUMP (OH) OFF Landing Distance (ft) 3.630 3.760 4.030 PTU (OH) OFF Engine Anti-Ice 1 – 4 (OH) ON Flight Deck Emergency Lighting (OH) ARM PREFLIGHT FLOWS YD 1 & 2 (CC) PRESS FLIGHT DECK SAFETY INSPECTION Confirm YD 1 & YD 2 annunciators illuminated Weather radar (CC) OFF Oxygen Main Valve (RSP) OPEN Tilt (CC) +15° FO Oxygen Regulator (RSP) TEST SUPPLY Transponder (CC) STBY Doors (EFB) OPEN Airbrake (CC) IN Airstairs (EFB) EXTEND Flaps (CC) UP Weights & Fuel (EFB) SETUP Landing gear lever (CP) DOWN Parking Brake (CC) SET YELLOW Brake Pressure (OH) CHECK 2.500PSI+ ESTABLISHING EXTERNAL & APU POWER Less? Turn ON the DC PUMP until sufficient pressure is reached. BATT 1 & 2 (OH) ON Thrust levers (CC) FUEL OFF Volt / Amp Meter (OH) CHECK 24V+ Hydraulics (OH) VERIFY OFF Navigation Lights (OH) HI INT CTR Tank Transfer (OH) AUTO No Smoking Signs (OH) AUTO Press. Mode Selector (OH) AUTO Cabin Emergency Lighting (OH) ARM Press. Disch. Valves (OH) NORMAL Brake Selector (CC) YEL Press. Alt (OH) SET CRZ LVL Yaw Damp Master 1 & 2 (OH) ON Ice Detect (OH) ON AP MSTR (OH) ON Fuel Qty (CP) VERIFY Avionics Master 1 & 2 (OH) ON Fasten Belts (OH) ON Anti-Skid (OH) ON Flight Data Recorder Date (RSP) SET TODAY YEL & GRN Lift Spoilers (OH) ON Flight Data Recorder Leg (RSP) 1 Bus-Tie AC & DC (OH) AUTO ATC/FID (CC) PRESS (FID) STBY INV & GEN (OH) ARM Flight Number (CC) ENTER Galley Switch (OH) ON (GALLEY) ATC/FID (CC) PRESS (ATC) GEN 1 & 4 (OH) OFF/RESET APU GEN (OH) ON BAe 146 Checklist & Procedures for MS Flight Simulator by PH-BKO (v1.2)
PREFLIGHT FLOWS (CONTINUED) ENGINE START
TAKEOFF PERFORMANCE CALCULATIONS BEFORE START PWR (TMS) PRESS (ON) AC Pump (OH) ON TEST (TMS) PRESS (PERFORM) Airstairs (EFB) RETRACT Verify test complete. Doors (EFB) CLOSE TREF (TMS) SET OAT AC Pump (OH) OFF TO (TMS) PRESS (ARM) Beacon Lights (OH) ON TGT (TMS) SET CLB TEMP APU Air (OH) OFF N1 Bug (CP)* SET TMS VALUE Packs 1 & 2 (OH) OFF TGT Bug (CP)* SET TMS VALUE Fuel Pumps 1 – 4 (OH) ON Takeoff Speeds (CP) VERIFY START PWR (OH) NORM ASI Reference Speeds (CPT)* SET START MASTER (OH) ON * Can be done automatically by clicking on the BEFORE START CHECKLIST flipchart. V-speeds are based on current flap Beacon ON position or flaps 18 if current flaps 0. Packs & APU Air OFF PWR (TMS) OFF Engine Anti-Ice ON AC Pump OFF NAVIGATION INSTRUMENTS AND RADIOS Start Power AS REQ. Flight Director Bars (GS) ON Start Master ON VHF NAV 1 Radio ON (GS) PRESS (ON) ENGINE START VHF NAV 1 Radio DME (GS) ON Navigational Radios (GS) SET AS REQ. Chocks (EFB) REMOVE Navigational Courses (GS) SET AS REQ. Pushback PERFORM AS REQ. HDG (GS) SET INITIAL HDG HDG (GS) PRESS (ARM) Start Selector (OH) ENG 4 ALT (GS) SET INTIAL ALT Engine Start Switch (OH) START (HOLD 1 SEC) ALT ARM (GS) PRESS Verify ENG IGN A & B ON + STARTER OPERATING lights illuminate. RMI / DBI (CPT) SET AS REQ. N1, TGT, N2 (CP) MONITOR HSI Source (CP) SET AS REQ. Thrust Lever Eng. 4 (CC) FUEL ON VHF COMM 1 & 2 (CC) ON At around 10% N2. VHF COMM 1 & 2 (CC) SET AS REQ. Confirm fuel flow and N1, TGT N2 rising. PREFLIGHT CHECKLIST Repeat for engines 3, 2, 1 when stabilized. Mobile Phone OFF Ext / Int Checks COMPLETE, COVERS & PINS Start Selector (OH) OFF STOWED START MASTER (OH) OFF Brakes YELLOW & PARK, PRESSURE Engine Anti Ice (OH) AS REQ. CHECKED GEN 1 & 4 (OH) ON Hydraulics ALL OFF APU AIR (OH) ON Fuel Panel CHECKED / SET Packs 1 & 2 (OH) ON Pressurization SET Brake Fans (OH) AUTO Ice Detect ON Eng. 2 & 3 Hydraulic Pumps (OH) ON Lights and Notices SET Confirm 3.000 PSI in both systems. Air Conditioning SET / CHECKED AC Pump (OH) ON Fasten Belts ON PTU (OH) ON Fuel CHECKED / TOTAL __ KGS / Heaters (OH) ON MIN. __ KGS PWR (TMS) PRESS (ON) Speeds / N1 CHECKED / BUGGED Transponder Mode (CC) TA IRS / FMS POSN RESET Briefing COMPLETE Ship’s Papers COMPLETE Flight Deck Door CLOSED & LOCKED BAe 146 Checklist & Procedures for MS Flight Simulator by PH-BKO (v1.2)
ENGINE START (CONTINUED) BELOW THE LINE
AFTER START CHECKLIST Cabin SECURE & WARNED Start Power NORMAL Controls CHECKED FULL & FREE Start Select & Master OFF MWS CHECKED Engine Anti-Ice AS REQ. Transponder ON Generators ON Radar / Terrain Display INOP Brake Fans AUTO Auto-Throttle NOT INSTALLED Hydraulics ON & CHECKED Lights / Strobes ON Heaters ON APU & Engine Air AS REQ. TAKEOFF & CLIMB Packs ON TAKEOFF ROLL Doors & Windows CLOSED Brakes HOLD Chocks & Ground Equipment CLEAR Thrust Levers (CC) 55% N1 Engines (CP) VERIFY STABLE TAXI Thrust Levers (CC) N1 REF BEFORE TAXI CONFIGURATION Brakes RELEASE Flaps (CC) 18 Taxi Lights (OH) ON INITIAL CLIMB Rudder trim (CC) CENTER Gear (CP) UP Aileron trim (CC) CENTER Flaps (CC) RETRACT Elevator trim (CC) WITHIN GREEN BAND When climbing through VFTO speed and 1.500 ft Clicking the CG% SMC box on the EFB sets the AGL. correct trim for takeoff. Autopilot (CC/GS) ENGAGE AS REQ. CONFIG CHECK (CC) PRESS & HOLD The AP is armed on the centre console, not on Config is correct when no horn audible. the glareshield CONT IGN A & B (OH) AS REQ. Engine Air 1 – 4 (OH) ON When standing water present on runway or APU Air (OH) OFF heavy precipitation in the area. SYNC (TMS) PRESS BEFORE TAKEOFF CHECKLIST MSTR (TMS) SELECT 1 Brakes YELLOW / GREEN CHECKED – Select engine 1 as MSTR engine, the TMS will YELLOW adjust engines 2, 3 and 4 to match the MSTR Flaps SET __ & CHECKED engine thrust. Flight Instruments CHECKED, QNH __ AC Pump (OH) OFF Trims 3-WAY SET FOR TAKEOFF PTU (OH) OFF Config CHECKED APU Master (OH) STOP Seats & Harnesses LOCKED & SECURED Cabin Call (OH) PRESS NAV Aids SET AS CLEARED AFTER TAKEOFF CHECKLIST T/O Briefing REVIEWED Gear UP, LIGHTS OUT Speeds / N1 CHECKED Flaps UP Continuous Ignition AS REQ. Engine Air ON BEFORE TAKEOFF APU Air OFF Cabin Call (OH) PRESS TRP CLIMB __ Cabin Secured slider (CC) SECURE FOR TAKEOFF PASSING 10.000 FT This happens automatically after confirmation. Landing Lights (OH) OFF Landing Lights (OH) ON Fasten Seatbelts (OH) OFF Strobe Lights (OH) ON Flight Controls CHECK TMS VERIFY TMS On, TO mode engaged, N1 REF shown. MWS VERIFY Captions extinguished, except appropriate green captions. GA Mode (CPT) ARM Press the small red button on the yoke. BAe 146 Checklist & Procedures for MS Flight Simulator by PH-BKO (v1.2)
CRUISE & DESCENT LANDING CHECKLIST
REACHING CRUISE LEVEL Altimeters QNH __ & X-CHECKED Thrust Levers (CC) REDUCE Gear DOWN, 3 GREENS TGT (TMS) SET AS REQ. Brakes YELLOW & CHECKED TGT Mode (TMS) ENGAGE NWS Steering CENTERED TGT mode can be used to hold a TGT value (600C Lights ON / AS REQ. – 700C seems good depending on weight). APU Air OFF / AS REQ. Engine Air OFF / AS REQ. Cabin SECURE & WARNED DESCENT PREPARATIONS Flaps SET FOR LANDING Rad Alt Decision Height (CPT) SET Air Switching AS REQ. Cabin Altitude Target (OH) SET FIELD ELEV. VREF speed (CP) VERIFY AFTER LANDING Landing Lights (OH) OFF DESCENT CHECKLIST Taxi Lights (OH) ON Pressurization CHECKED / SET Strobe Lights (OH) OFF Briefing / Terrain Display COMPLETE / INOP TMS PWR (TMS) OFF Landing Data CHECKED / SET Transponder (CC) STBY Landing Flap Switch 24/33 SET CONT IGN A & B (OH) OFF Seats & Harnesses LOCKED & SECURED AFTER LANDING CHECKLIST DESCENT Auto-Throttle NOT INSTALLED DESC Mode (TMS) ENGAGE Air Brakes & Lift Spoilers IN PTU (OH) ON Flaps UP Radar / Transponder INOP & STANDBY APPROACH & LANDING APU AS REQ. INITIAL APPROACH (PASSING 10.000 FT) APU Air AS REQ. Landing Lights (OH) ON Engine Air AS REQ. Fasten Belts (OH) ON Engine Anti-Ice & Ignition AS REQ. Navigational Radios (GS) SET AS REQ. Navigational Courses (GS) SET AS REQ. LIMITATIONS APU Master Switch (OH) START AS REQ. Maximum Operating Speed 295 KIAS Monitor APU RPM & TGT rise. (VMO) APPROACH CHECKLIST Maximum Operating Mach M 0.70 Number Altimeters QNH __ & X-CHECKED Landing Gear Operating Speed 205 KIAS Fasten Belts ON (VLO/VLE) APU AS BRIEFED Maneuvering Speed (VA) 220 KIAS (FL. UP) Fuel Panel SET 175 KIAS (FL. 18) APPROACH Flaps UP max speed VMO Cabin Call (OH) PRESS (En-route / normal hold) Cabin Secured slider (CC) SECURE FOR LANDING Flaps 18 max speed 210 KIAS This happens automatically after confirmation. (TO / APP) Flaps (CC) 18 Flaps 18 max speed 175 KIAS AC Pump (OH) AUTO (Low speed hold) APU Air (OH) ON Flaps 24 max speed 180 KIAS Engine Air (OH) OFF (TO / APP / CLB) Brakes (OH) YEL Flaps 30 max speed 170 KIAS (TO) FINAL APPROACH Flaps 33 max speed 145 KIAS Gear (CP) DOWN (LND) Flaps (CC) SET AS REQ. ASI Reference Speeds (CPT) SET Can be done automatically by clicking on the flipchart. Airspeed REDUCE (VREF + 10) BAe 146 Checklist & Procedures for MS Flight Simulator by PH-BKO (v1.2)
SHUTDOWN & SECURE SECURE CHECKLIST
PARKING Avionics OFF Taxi Lights (OH) OFF Oxygen Main Valve OFF Parking Brake (CC) SET Master Switches OFF Chocks (EFB) SET Anti-Skid & Lift Spoilers OFF MWS GRND OP (CP) PULL Cabin / Cockpit Emergency Lights OFF Hydraulic Pumps (OH) OFF Packs OFF Gen 1 – 4 (OH) OFF/RESET APU Air OFF Thrust Levers (CC) FUEL OFF APU TESTED OVERSPEED Fasten Belts (OH) OFF Lights AS REQ. Fuel Pumps (except L INNER) (OH) OFF Battery OFF Heaters (OH) OFF Ice Detection (OH) OFF Beacon Light (OH) OFF Doors OPEN Airstairs EXTEND SHUTDOWN CHECKLIST Brakes YELLOW & PARK Hydraulics ALL OFF Gen 1 & 4 OFF / RESET Thrust Levers FUEL OFF Fasten Belts OFF Taxi Lights OFF Brake Fans AS REQ. Fuel Pumps OFF Engine Anti-Ice OFF Heaters OFF Ice-Detect OFF Beacon OFF Mobile Phone AS REQ. Flight Deck Door UNLOCKED SECURING THE AIRCRAFT Yaw Damper Master 1 & 2 (OH) OFF AP Master (OH) OFF Avionics Master A & B (OH) OFF Brake Fans (OH) OFF Anti-Skid (OH) OFF YEL & GRN Lift Spoilers (OH) OFF Cabin Emergency Lights (OH) OFF Pack 1 & 2 (OH) OFF Flight Deck Fan (OH) OFF Cabin Fan (OH) OFF APU Air (OH) OFF APU OVSPD (OH) PRESS AND HOLD Fuel Pumps (OH) OFF Galley Switch (OH) SHED Exterior Lighting (OH) OFF Emergency Lighting (OH) OFF Interior Lighting (OH) OFF BATT 1 & 2 (OH) OFF