Professional Documents
Culture Documents
3 NTS NTDCL DEC 2022 Paper 3 (DONE)
3 NTS NTDCL DEC 2022 Paper 3 (DONE)
Superposition
charged particle in a uniform magnetic field is
directly proportional to? 08. In order to get maximum power transfer from
A. Flux density of the field a capacitive source, the load must
B. Particles Energy A. Have a capacitive reactance equal to circuit
C. Particles Momentum resistance
D. Particle’s charge B. Have an impedance that is the complex
conjugate of the source impedance
02. A tunnel diode is C. Be as capacitive as it is inductive
A.A heavily doped PN junction device D. None of the above
B. A lightly doped PN junction device
C. Has a small tunnel in its junction 09. Free space is ……..
D. Is a gallium arsenide device A. Conductor
B. Insulator
03. Which operation is not performed on C. Bad conductor
independent variables? D. Insulator because of lack of free electrons
A. Time shifting
B. Time reversal 10. In thyristor is turned-off when the anode
C. Time scaling current falls below
D. Amplitude scaling A. Forward current
B. Latching current
04. For what purpose a moderator is used in C. Holding current
nuclear power plants? D. Break over current
A. Stop the chain reaction
B. Accelerate the speed of neutrons 11. Ampere hour is the unit of
C. Reduce the speed of neutrons A. Charge
D. To absorb neutrons B. Power
C. Energy
05. The _________ is an electromagnetic carrier D. Current
wave which is modulated to carry information?
A. Air 12. A Triac is a semi-conductor device which acts
B. Sound as a
C. Light A. 2 terminal unidirectional switch
D. Electricity B. 2 terminal bidirectional switch
C. 3 terminal bidirectional switch
06. The analog to digital convertor D. 4 terminal multidirectional switch
provides---------of inputs signal.
A. Representation 13. In the memory format date is used for
B. Quantization transmitted for communication?
C. Maximum value A. Application
D. Incomplete information B. Presentation
C. Physical
07. The principle of _____ can be used to analyze D. Protocol
fault in power system network.
A. Thevenin 14. |1 3 5| order of matrix is
B. Norton A. 1 by 1
C. Jordon B. 2 by 3
16. Current in the Open circuit is 23. The number of diodes used for full wave
A. Infinite rectifier
B. Zero A. 3
C. Low B. 2
D. High C. 5
D. 1
17. Diodes is a -----------
A. Linear 24. RC snubber circuit is used to limit across the
B. Bilateral A. Rise of current in SCR
C. None Linear B. Rise of dv/dt ratting
D. None of these C. conduction period
D. None
18. Ohm’s law is not applicable for
A. Low Dc circuit
B. Linear Network 25. The pressure in the working fluid. cycle of a
C. Largest resistance thermal power plant is developed by
D. Non-linear Circuit A. condenser
B. feedwater pump
19. Which of the following is NOT a purpose of C. superheater
Disturbance Monitoring? D. turbine
A. Model validation
B. Disturbance investigation 26. A turbine with rated speed of 250 rpm,
C. incorrect relay setting connected to a synchronous generator, must
D. Assessment of system protection performance produce power at 50 Hz. The generator must have
A. 4 poles
20. Electrical current always chooses the path B. 8 poles
A. High conductive path C. 16 poles
B. Low conductive D. 24 poles
C. High resistive
D. Least Resistive 27. The rated voltage of a 3-phase system is
reported as
21. Shunt reactors used in transmission line A. Peak line-to-line voltage
A. Reduced the short circuit current B. Peak phase voltage
B. limit the fault current C. RMS line-to-line voltage
C. limit the open circuit current D. RMS phase voltage
D. compensate the voltage drop in the line
28. The insulation strength of a high voltage
22. Power generation cost reduces as
30. The power factor is said to be leading when 37. The solar cell is a PN-junction operating in:
A. the current leads the voltage A. reverse bias
B. the current lags the voltage B. forward bias
C. the voltage leads the current C. unbiased
D. the voltage is in phase with the current D. Semi biased
31. Power factor correction is the method of 38. The electrical length of a transmission line is
connecting based on the
A. a capacitor in series with an inductive load A physical length of the line
B. a capacitor in parallel with an inductive load B. wavelength of the AC on the line
C. an inductor in series with an inductive load C. nominal voltage of the line
D. a capacitor in series with a capacitive load D. power transmitted over the line
32. The efficiency of a thermal power 39. The surge impedance of a long power
plant improves with: transmission line is of the order of:
A. The increased quantity of coal burnt A. 500 ohm
B. A larger quantity of water used B. 750 ohm
C. Lower load in the plant C. 400 ohm
D. Use of high steam pressures D. 800 ohm
33. A condenser in a thermal power plant 40. Skin effect is proportional to which of the
condenses steams coming out of: following?
A. Boiler A. Diameter of conductor
B. Turbine B. (diameter of conductor)1/2
C. Super-heater C. (diameter of conductor)2
D. Economizer D. (diameter of conductor)3
34. Which variety of coal has a lowest calorific 41. The output of a solar cell is of the order of:
value? A. 0.5 W
A. Steam coal B. I W
B. Bituminous coal C. 0.1 W
44. In pneumatic control system, compensation is 51. A smart grid cannot include
provided by: A. smart meters
A. Bimetal strip B. intelligent devices
B. Extension tube C. real-time controls
C. Restriction-volume combination D. conventional electrical systems
D. None of the above
52. Which of the following is not an enabled
45. Which of the following sequence is correct for application of smart grids?
a three term controller? A. fossil fuel storage
A. DIP B. micro grid
B. IDP C. energy storage
C. PDI D. plug-in electrical vehicle
D. PID as well as PDI
53. The ratio error of a current transformer is due
46. The accuracy of an instrument is determined to:
by the A. Lagging power factor
A. how close is the measurement to the true value B. Stray magnetism
B. how close is the measurement to a fixed value C. Corona effects
C. how close are different measurements of the D. Exciting current
same quantity
D. how close are different measurements of 54. Which of the following instruments does NOT
different quantities use the effect of current for measurement
purposes?
47. Candela is a SI unit of A. Electrostatic ammeter
A. luminous flux B. Hot wire ammeter
B. luminous power C. Rectifier ammeter
C. luminous intensity D. Moving coil ammeter
D. illumination independently
55. Linear differential transformer is an:
59. Chain reaction in a nuclear reactor is 66. Brushes for commutators for 220 V DC
controlled by using generator are generally made of:
A. Thorium A. Copper
B. Uranium B. Electro graphite
C. Plutonium C. Silver
D. Boron D. Cost iron
60. Displacement factor is the ratio of 67. In a small DC machine, the yoke is made of:
A. active power to apparent power A. Stainless steel
B. reactive power to apparent power B. Mild steel
C. reactive power to active power C. Cast iron
D. active power to reactive power D. Grain oriented steel
61. Which of the following does not determine 68. Alternating voltages and currents
AC power quality? are expressed in R.M.S. Values because
A. Total harmonic distortion A. They can be easily determined
B. Frequency fluctuation B. The calculations become very simple
C. Voltage fluctuation C. They give a comparison with D.C
D. Average power D. None of the above