You are on page 1of 11

Electrical Engineering MCQs Search …

Search
 admin  May 28, 2021  6:19 pm

Categor
Computer
Electrical
Engineering
English
General
Knowledge
Islamic
Studies
Pakistan
Studies
Pedagogy
PESCO
Top 100 Electrical Test

Engineering Jobs MCQs


Science

in Pakistan Tags
Education MCQs
Electrical Engineering
1. Which transformer side has a low cross-sectional area: Electric Engineering
MCQs English MCQs
A) Primary Winding Holy Quran MCQs
B) Secondary Winding
C) High Voltage Winding Islamic
Islamic

D) Low Voltage Winding MCQs Islamic


Studies Koran MCQS
2. When two dices are thrown What is the probability of not NTS Pedagogy
appearing the same number on the dices? NTS Test
A) 5/6 Pakistan Study Pak
B) 1/6 Study MCQs Pedagogy
C) 2/3 Online Test PESCO
D) 1/3 MCQs Quran Quran
Quranic
Facts
3. linear differential transformer is which type of Knowledge
_______transducer?
A) Electromechanical Quran
B) Inductive
C) Chemical
MCQs SST
MCQs SST Test
D) Piezoelectric
Preparing Surah Vitamin
4. A moving iron ammeter coil has few turns of thick wire in order A Vitamin B Vitamin B1
to have:
A) Low resistance
B) High sensitivityC) Effective damping
D) Large scale
5. The field last as long as the current flowing in the wire
[adsforwp id=”3715″]
(A) Electric field
(B) Magnetic field
C) Gravitational Field
D) None of these
6. Data travel fastest in ______ Cable?
A) Unshielded Twisted Pair
B) Shielded Twisted Pair
C) Coaxial
D) Fiber Optics
7. The self-inductance of solenoid depends on:
A) Length
B) Cross-sectional area
C) Thickness of the conductor
D) All of the above
8. Power transformer transforms??
A) Power
B) Voltage
C) Current
D) Resistance
9. Maxwell bridge is used to measure______ ?
A) Resistance
B) Inductance
C) Capacitance
D) Frequency
10. Moving Coil ammeter can measure
A) AC current
B) DC Current
C) Eddy Current
D) Stray Current
Also Read: 1000+ GENERAL KNOWLEDGE MCQS FOR NTS, FPSC
And Other JOBS in Pakistan
[adsforwp id=”3715″]
11. Unit of potential difference?
A) Volt
B) Ampare
C) Ohm
D) Henry
12. Find Q when current is 0.2A in a period of 2 minutes
A) 13C
B) 18C
C) 24C
D) 29C
13. 25% is 150 then for the full cycle then the valve will be_____?
A) 200
B) 350
C) 500
D) 600
14. A digital signal is what in
A) Discrete in time
B) Discrete in amplitude
C) Discrete in neather time nor amplitude
D) Discrete in both amplitude and time
15. The unit of Electric Energy is
A) Volt Amp
B) KW
C) kWh
D) Joule
16. In DC motor which loss decreases with increase in load
A) Friction and Windage Loss
B) Core
C) Brush Contact Loss
D) None of these
17. A constant current transformer should not have
A) Moveable Secondary Winding
B) High Resistance
C) Primary and Secondary Winding Surrounding Core
D) Low resistance
18. In piston maximum temperature is at:
A) Ring Set
B) Gudgeon Pin
C) Top Sides
D) Top Centre
19. P = 3000KW, d = 30km transmission line voltage will be:
a) 11KV
b) 66kV
c) 33KV
d) 132KV
20. Coal which has lowest calorific value:
a) Steam coal
b) Bituminous
c) Lignite
d) Anthracite
Also read: 230+ Repeated NTS MCQs with answers
21. Graphic representation between discharge and time is called:
a) Monograph
a) Monograph
b) Hectograph
c) Topograph
d) Hydrograph
22. Coal from storage to the boiler is taken through_____?
a) Buckets
b) V-ballets
c) Trolleys
d) Manually
23. The main drawback of a feedback system is:
a) Inaccuracy
b) Inefficiency
c) Insensitivity
d) Instability
24. What does phase margin specify ______?
a) Absolute Stability
b) Relative Stability
c) Frequency response
d) None of these
25. Non-linearity caused by servomotor is due to:
a) Coulomb friction
b) Dead space
c) Saturation
d) Dissemination
26. In force-voltage analogy, Inertia is analogous to:
a) Capacitance
b) Inductance
c) Inverse of capacitance
d) Inverse of Inductance
27. Pole shoes of DC machine fastened to pole core by:
a) Welding
b) Soldering
c) Steal Clamp
d) Counter Sunk
28. Brushes on commutator are shifted from GNP to:
a) To obtain the highest generated voltage
b) Avoid sparking
c) To increase generated efficiency
d) To produce sparking
29. admittance is reciprocal of:
a) Impedance
b) Capacitance
c) Inductance
d) Resistance
30. Power in AC is consumed by:
a) Inductor
b) Capacitor
b) Capacitor
c) Resistance
d) All
31. Negative maximum of cosine waveform is
a) 180 degree
b) 30 degree
c) 45 degree
d) 90 degree
32. RF chokes are air cored to:
a) Keep frequency low
b) Keep inductive reactance low
c) To keep frequency high
d) To keep inductive reactance high
34. Instantaneous of sinusoidal AC current at 45 degrees is
called_____?
a) Peak-peak
b) RMS
c) Peak current
d) Average
35. In a common base amplifier output voltage is taken from
a) Collector
b) Emitter
c) Base
d) both A & C
36. The form factor is the ratio of:
a) Avg to rms
b) Peak to rms
c) Rms to avg
d) Peak to avg
37. The process of AC to Dc conversion is called ______
A) Inversion
B) Clipping
C) Cyclo-Conversion
D) Rectification
38. A.C. servomotor resembles
(a) Two phase induction motor
(b) Three phase induction motor
(c) Direct current series motor
(d) Universal motor
39. A transfer function of a system is used to calculate which of
the following?
(a) The order of the system
(b) The time constant
(c) The output for any given input
(d) The steady state gain
40. For constant voltage transmission, the voltage drop is
compensated by installing
a) Synchronous motor
b)Capacitor
C) Inductor
d) All of these
41. Hydrogen is used for Cooling of large size generators,
because:
a) It has the high thermal conductivity
b) It is light
c) It offers reduced fire risk
d) All of the above
42. In a transmission line following arc the distributed constraints
A) resistance and inductance
B) resistance, inductance and capacitance
C) resistance, inductance and capacitance, and short
conductance
D) None of these
43. If a signal having different frequency and different sampling
frequency are time division multiplexes then it is known as
__________?
a) Pulse stuffing
b) Synchronous multiplexing
c) Asynchronous multiplexing
d) FDMA
44. Which of the following TV system is adopted in PAK
A) SECAM
B) NTSC
C) PAL
D) ADALAH
45. The differential transformer is a _________ device?
a) electromagnetic
b) electromechanical
c) electrostatic
d) None of these
46. the parabolic antenna is used in satellite tracking because it
has:
a) good maneuverability
b) good front to back ratio.
c) high bandwidth
d) All of these
47. headphone and speaker are
A) Video input
B) Audio input
C) Audio output
D) None of these
48. heterodyne frequency shifter is also called.
a) Mixer
b) Frequency translator
c) Frequency shifter
c) Frequency shifter
d) Frequency multiplier
49. Which relay is used in long-distance transmission lines?
A) Mho relay
B) Impedance relay
C) Admittance relay
D) None of these.
50. When the signal is first compressed before modulation and
decompressed after demodulation in order to achieve the same
quantization level is called______?
a) Companding
b) Pre-emphasis
c) De-emphasis
d) Quantization
51. At Unity Power Factor, Armature Flux is??
A) Cross Magnetizing
B) Demagnetizing
C) Zero
D) None of these
52. In radio, receiver squelch circuit is used to:
a) Reduce RF interference
b) Catch weak signals
c) Reduce noise
d) Cutt off and to amplify between stations
53. the autocorrelation function is
a) An odd function in to
b) An even function in to
c) An exponential function in to
d) None of these
54. The probability density function of thermal noise is:
A) Binomial
B) Gaussian
c) Poisson
d) None of these
55. Correct for a three-term controller?
a) PID
b) PIC
c) PD
d) All of these
56. When the current in the light bulb decreases by 2%, its power
decreases by _____?
a) 4%
b) 2%
c) 8%
d) 40%
57. The LTI (Linear Time Invariant) system can be completely
characterized by
a) Ramp input
b) Sinusoidal input
c) Impulse response
d) Step input
58. Which meter is used a null detector in Wheatstone bridge
a) Ammeter
b) Voltmeter
c) Ohm-meter
d) Galvanometer
59. The fact that a conductor carries more current on the surface
as compared to the core is known as:
a) Faraday’s effect
b) Ampere’s Effect
c) Corona
d) Skin effect
60. if the carrier of a 100% modulated AM wave is suppressed the
percentage of Power
A) 50
b) 66.66
c) 100
D) 150
61. Burning material such as wood, paper, and textile constitute a:
a) Class A
b) Class B
c) Class C
d) Class D
62. If the height of the transmission towers is increased, which of
the following parameters is likely to change?
a) Capacitance
b) Inductance
c) Resistance
d) No change
63. Execution of program instruction in a computer takes place in:
a) Ram
b) Memory
c) CPU
d) Monitor
64. If z transform lies in ROC then
A) System is stable
B) Inverse of system is stable
C) Both system and its inverse are unstable
D) Both system and its inverse are stable
65. A diode that has negative resistance characteristics is the
A) Schottky diode
B) Tunnel diode
C) Hot-carrier diode
D) Laser diode
66. Silicon atomic number is 14 its valency is
A) =4
B) <4
C) >4
D) 7
67. Which bulb operates on the lowest power
A) Night bulb
B) Neon bulb
C) GLS bulb
D) Torch lamp
68. The channel of a JFET is between the
A. Gate and drain
B. Drain and source
C. Gate and source
D. Input and output
69. A moving iron ammeter coil has few turns of thick wire in order
to have:
A. Low resistance
B. High sensitivity
C. Effective damping
D. Large scale
70. Solid grounding is used for voltages
a. above 220 kV
b. above 11 kV
c. below 660 V
d. below 115 V
71. Ac power is used for the transmission line to____________?
A) To minimize losses
B) To minimize cost
C) To get maximum power
D) None of these
72. A 0.05 MW is equal to ______KW
A) 5kw
B) 50kw
C) 500kw
D) 5000kw
73. 800mv is equal to…Volts.
A) 0.008v
B) 0.08V
C) 0.8V
D) 8V
74. Electrical lines of force about a negative charge are
A. Circular, anticlockwise
B. Circular, clockwise
C. Radial, inward
D. Radial, outward
75. A rectifier is a _____?
A. Bilateral device
B. Linear device
C. Non-linear device
D. Passive device
76. If we have two nodes A and B and Vab is the potential
difference between these nodes then which node is called
reference node
a. Node A
b. Node B
c. Ground Node
d. None of These
77. If current and voltage are out of phase by 90 degrees then
power is _____?
A) Maximum
B) Minimum
C) ZERO
D) None of These
78. In AC circuit power is consumed by _____?
A) Resistance
B) Capacitance
C) Inductance
D) All of these
79. the principal of ……….can be used to analyze fault in power
system network.
A. Thevniin
B. Norton
C. Jordon
D. Superposition
80. A _____ meter is used a null detector in Wheatstone bridge
A. Ammeter
B. Voltmeter
C. Galvanometer
D. None of these
81. In 3-phase 4-wire system, how many voltages are available?
a. Two
b. Three
c. Four
d. Nine
82. ______ is defined as the measure of an instrument by which it is
error-free
A) Accuracy
B) Precision
C) Resolution
D) None of these
83. For single phase rotary converter, when the power factor is
unity, the AC line to DC current ratio will be.
A) 1.4
B) 1.0
C) 0.707
D) 0.5
84. Rohtas Fort was built by? Sher Shah Suri
85. The biggest market of Pakistan’s Imports and Exports is? USA
86. The first wife of Hazrat Mohammed (PBUH) was Hazrat Bibi
khadeeja
87. To which Prophet the Zabur was revealed by Allah? Prophet
Dawood (A.S)
88. Prophet Muhammad (PBUH) had how many sons? 3 Sons
89. Lyallpur is in? (Faisalabad)
90. Financial year of Pakistan starts from? 1st July
91. Which country won the Cricket World Cup in 1999? Australia
92. The largest Natural fresh Water Lake in the subcontinent
is Keenjar Lake
93. Capital of Turkey? Ankara
94. Pakistan Islamic state (1956)
95. Suggestion to ditch a dig (Hazrat Salman)
96. The capital of Australia (Canberra)
97. Pakistan’s membership opposed in UNO by (Afghanistan)
98. National animal of Pakistan (Markhor)
99. Dia-mir Bhasha dam is located on which of the following
river? River Indus
100. Sajan Jandal business tycoon visited Pakistan in April 2017
Most Repeated MCQs for Jobs, Interviews and Tests in Pakistan:

General Knowledge MCQs

English MCQs

Pakistan Studies MCQs

Islamic Studies MCQs

Everyday Science MCQs

You might also like