Professional Documents
Culture Documents
4G Drive Test Parameters
4G Drive Test Parameters
RSRP
RSRP :- Reference signal receive power.
Range :- -3 to -19.5 dB
SINR = S / I + N
RSSI=12*N*RSRP
RSSI per resource block is measured over 12 resource
elements.
Range :- 1 to 15
Better the CQI better the throughput will get and vice versa.
CQI Plot & Threshold
PCI
PCI :- Physical Cell Id
Range :- 0 to 503
Downlink Throughput
- In E-UTRAN may use a maximum of 2 Tx antennas at
the ENodeB and
2 Rx antennas at the UE ( MIMO ).
Where
POL is the uplink power, set by open loop power control. The
choice of alpha depends on whether conventional or fractional
power control scheme is used. Using alpha = 1 leads to
conventional open loop power control while
0 < alpha < 1 leads to fractional open loop power control
Pmax is the maximum allowed power that depends on the UE
power class
M is the number of assigned resource blocks as indicated in the UL
scheduling grant
P0 is a UE specific parameter with 1 dB resolution
PL is the downlink path loss calculated in the UE from a RSRP
measurement and signaled RS transmit power
Closed Loop power Control
Closed loop power control is capability of the UE to adjust
the uplink transmit power in accordance with the closed
loop correction value also known as transmit power control
(TPC) commands. TPC commands are transmitted, by the
eNB towards the UE, based on the closed loop signal-to-
interference and noise ratio (SINR) target and measured
received SINR. In a closed-loop power control system, the
uplink receiver at the eNB estimates the SINR of the
received signal, and compares it with the desired SINR
target value. When the received SINR is below the SINR
target, a TPC command is transmitted to the UE to request
for an increase in the transmitter power. Otherwise, the TPC
command will request for a decrease in transmitter power.
Thanks