Professional Documents
Culture Documents
Documents - Tips Drilling Engineering Fall 2012 Prepared by Tan Nguyen Drilling Engineering
Documents - Tips Drilling Engineering Fall 2012 Prepared by Tan Nguyen Drilling Engineering
The drilling mud travels up the stand pipe and through the rotary hose, and then
downward through the kelly or top drive system, drill pipe and bottomhole assembly
by the mud pumps. It exists the drill string through the bit nozzles and picks up drill
cuttings from the bottom of the hole. It then carries the cuttings up the annulus, past
the blowout preventers, and through the mud-return line to the shale shaker. At the
shale shaker, the larger cuttings are screened out and diverted to a "reserve pit"
(actually a waste pit). Desanders, desilters and centrifuges may be used to filter out
smaller particles. The mud flows into a settling tank or pit and finally, it returns
through the sump to the suction pit to repeat the circuit.
Auxiliary System
Drilling fluid maintenance system
There are two types of auxiliary systems associated with the basic circulating
system: the drilling fluid maintenance system and the well pressure control system.
The drilling fluid maintenance system includes the shale shaker (a set of rotating or
vibrating screens, which removes the larger drill cuttings from the returning mud and
serves as the sampling point for drill-cuttings analysis); mud guns and mud-pit
agitators for maintaining a uniform content of mud solids; cone-type desanders,
desilters, and centrifuges to remove contaminants that would not otherwise settle
out; and a mud-gas separator and vacuum degasser for removal of entrained gases.
Auxiliary System
Drilling fluid maintenance system
Shale Shaker
Auxiliary System
Drilling fluid maintenance system
Auxiliary System
Drilling fluid maintenance system
http://www.youtube.com/watch?v=82VXx-tEpnQ
Auxiliary System
Well pressure control system
BOPs
BOPs
http://www.youtube.com/watch?v=kBQdTv7bspM
Mud Pumps
Triplex pumps have three cylinders, and are generally single-acting pumps
As the plunger (A) moves to the right, the fluid is compressed until its pressure exceeds the
discharge pressure, and the discharge check valve (B) opens.
The continued movement of the plunger to the right pushes liquid into the discharge pipe.
As the plunger begins to move to the left, the pressure in the cylinder becomes less than that
in the discharge pipe, and the discharge valve (B) closes.
Further movement to the left causes the pressure in the cylinder to continue to decline until it
is below suction pressure. At this point the suction check valve (C) opens.
As the plunger continues to move to the left, the cylinder fills with liquid from the suction.
As soon as the plunger begins to move to the right, it compresses the liquid to a high enough
pressure to close the suction valve (C), and the cycle is repeated.
The volume displaced by each piston during one complete pump cycle is given by
The pump factor for a single-acting pump having three cylinders becomes
Duplex pumps have two cylinders, and are generally double-acting pumps
Duplex pumps are double-acting, with two cylinders. Each of the two cylinders is
filled on one side of the piston at the same time that fluid is being discharged on the
other side of the piston. With each complete cycle of a piston, mud is discharged at
twice the volume of the cylinder minus the volume of the piston rod.
When the piston moves to the right, the liquid in the cylinder to the right of the piston
(E) is discharged, and the cylinder to the left of the piston (F) is filled.
When the direction of the piston is reversed, the liquid in F is discharged, and the
cylinder at E is filled with suction fluid.
Thus, the total volume displaced per complete pump cycle by a pump having two
cylinders is given by
Example
Consider a triplex pump having 6-in liners and 11-in strokes operating at 120
cycles/min and a discharge pressure of 3000 psig. Compute
Example