Calculate each of the following integrals by selecting
a proper method.
𝟏 i. 𝟏 +𝐬𝐢𝐧 𝒙 𝒅𝒙
ii. 𝒙𝒅 𝒙 𝟐 𝐬𝐨𝐜 𝒙 𝟐𝐧𝐢𝐬
iii. 𝒙𝒅 )𝒙 𝐧𝐥( 𝐧𝐢𝐬
𝟏 𝒅𝒙 iv. 𝟎 𝟒−𝒙𝟐
𝟐 v. sec 𝒙 + cot 𝒙 𝒅𝒙 iv v Q2
Apply disk and cylindrical shell methods to calculate the
volume of the solid formed by revolving the region bounded by 𝒚 = 𝒙, 𝒚 = 𝟐𝒙, 𝒚 = 𝟐, about the 𝒙-axis.
i. Clearly show the two methods’ selection by choosing
differential elements to calculate the volume in each case?
i. Evaluate your answer.
Q3 A plate of unitary areal density has the shape shown i. Construct an integration to calculate the moment of inertia about the 𝒙-axis. ii. Calculate the moment of inertia about the 𝒙-axis. iii.Repeat calculating the moment of inertia about the y-axis. Q4 The box shown in the Figure contains oil of density 932 kg/m3. The opening at location 𝑨 is a triangle of 0.75 m height and 0.75 m base.
i. Set all parameters that are required to
calculate the hydrostatic force acting on the opening 𝑨.
ii. Generate an integration to calculate the
hydrostatic force on the opening 𝑨.
iii. Calculate the hydrostatic force.
Q6
A cylindrical tank 4 m in diameter is lying on its side and is half full of
water of specific volume ( 𝜸 = 𝟗𝟖𝟎𝟎 𝑵Τ𝒎𝟑 ). Use integration to formulate steps lead to find the total force exerted on one end of the tank using 𝒙𝟐 + 𝒚𝟐 = 𝑹𝟐 , where 𝑹 is the radius of the cylindrical tank. i. Draw a side view for the cylinder and then show the axial view (the end of the cylinder). Show this end in 𝒙𝒚-coordinating system. What are the parameters needed to find the force?
ii. Formulate an integration to calculate the force.
Q7
A cylindrical tank 4 m in diameter and 6 m in length is lying on its side
and is half full of water of specific volume (𝜸 = 𝟗𝟖𝟎𝟎 𝑵Τ𝒎𝟑 ). Use integration to formulate steps lead to find the required work to empty the tank to height of 7 m above the axial center. You may use the equation of the circle 𝒙𝟐 + 𝒚𝟐 = 𝑹𝟐 , where 𝑹 is the radius of the cylindrical tank. i. Draw a side view for the cylinder and then show the axial view (the end of the cylinder). Show this end in 𝒙𝒚-coordinating system. What are the parameters needed to find the required work?
ii. Formulate an integration to calculate the work.