Professional Documents
Culture Documents
1
Well Testing
2. Various types of surface pressure tests (usually for gas wells).
This data is also used to calculate bottom-hole pressures
Used to determine
• formation permeability
• boundary conditions of reservoir
• formation pressures
• fluid (oil and water), and gas recovery from formation
2
DST tool schematic 3
FpfP = final pre-flow pressure
FFP = final flowing pressure
FHP = final hydrostatic pressure
FSIP = final shut-in pressure
IFP = initial flowing pressure
Pre-flow
IHP = initial hydrostatic pressure
Main FSI
ISI period IpfP = initial pre-flow pressure
flow or
period ISI = initial shut-in
Final
Pressure
1
4
FFP
IFP
IpfP 2 FpfP Time (~hours)
1 2 3 4 5 6 7 8 9 10 11 12
3. The purpose of the initial shut-in period is to record the reservoir pressure before any production has
occurred. It is important to have an initial shut-in period long enough to extrapolate a maximum
reservoir pressure. Many times it is too short to determine a reliable extrapolated reservoir
pressure. This can make it more difficult to determine if the reservoir is of limited areal extent.
When the initial shut-in period is complete, the tool is again opened. The purpose of this second
flowing period (Main Flow) is to allow reservoir fluid and gas to enter the drill string. Analysis of the
final flow data will help determine the flowing capabilities of the tested reservoir. Depending on
conditions, when the tool is opened the pressure will drop from reservoir pressure to the pre-flow
pressure and will record the weight of the formation fluid entering the drill string. If gas is present the
flowing pressure will reflect the upstream pressure of the gas flow.
5
4. The duration of the final flow period (Main Flow) should be about 60 to 180 minutes, depending
on conditions and estimated permeability. The air blow at the surface will indicate whether
formation fluid or gas is entering the drill string. If gas flows to the surface a stabilized
measured rate is desirable for proper reservoir evaluation.
When the final flow period is concluded the tool is again closed for a second shut-in period
(Final Shut-in Period) which stops the flow of fluid and gas into the drill string. The pressure
below the packer is then allowed to build. The duration of the Final Shut-In Period should be
about 1.5 to 2 times as long as the Main Flow (second flowing period), depending again on
conditions and estimated permeability. In low permeable zones, longer shut-in times are
necessary for proper reservoir evaluation.
5. The purpose of this second shut-in period (Final Shut-in Period) is to once again measure the
reservoir pressure after a certain amount of production has occurred. Remember, during this
test period, fluid and/or is not being recovered. Only pressure is being measured. Proper
evaluation of the second shut-in data will help determine if the tested reservoir is of limited
areal extent. Skin damage, permeability, radius of investigation, and other reservoir parameters
can also be determined.
6. At the end of the Final Shut-in Period, the packer is released which allows the drilling fluid to
flow from the borehole annulus and into the test zone. Hydrostatic pressure is then recorded for
a second time. Because the pressure should be equalized (sometimes the packer gets stuck),
the packer can be easily be unseated from against the borehole walls so the tool can be
recovered.
6
Water and/or
hydrocarbons Hydraulic valve
recovered in closed
drill pipe
during this
flow period Bypass ports
open
Expanded
packer Packer deflated
to avoid
Pressure swabbing
recorded
in both
flow and
shut-in
periods
7
Main Flow Period Shut In Period Tripping out (or in)
Pressures are at test depth
Hydrostatic pressure
Tool open
Initial flowing pressure
Final flowing pressure
Tool closed
Shut-in pressure
Pipe recovery