Detailed information about Battery, Motor Specifications of Motor, Transmission, Battery The Electric two wheeler, which runs with battery, is the new technology which is under development. Present technology is handled with mechanical energy conversion. Mechanical energy converted into rotatory motion by piston arrangement. At present available engines are 4 stroke engine it has four stages. Suction, X Compression, Power & Exhaust. These stages are repeated in cyclic manner. Such type of arrangements are not required in electric two wheeler. The battery is directly connected to the motor (Which converts electric energy in to rotatory motion) then after transmission. The electric two-wheeler is light weight, cheapest vehicle which is best fitted for present environmental conditions. The battery has 72 V, 50 A. The oil tank in two wheeler is replaced by battery arrangement. This battery is used to starting the motor. Always ensure battery in fully charged conditions. This arrangement consists 12 V, 50 A The Motor is a device which converts electric energy into rotatory motion. Motor are basically three types. 1) Series Motor 2) Shunt Motor 3) Compound Motor. In our electric tow – wheeler we are using shunt motor because of its characteristics Battery (72 V, 100 A) Consists of twelve 12 V, 50 A batteries, Battery is used to start the motor. Check and top up at initial 1000 km and at very 3000 km thereafter.
Visually inspect the surface of the battery assembly container. If
any sign of cracking of electrolyte leakage from sides of the battery assembly noticed, replace the battery assembly with a new one. If the battery assembly lead terminals are found rusty with an acidic white powdery substance, then clean them with sand paper. Add only distilled water, as necessary to keep the electrolyte above the lower level line but not above the upper level line. Periodically check the electrolyte for specific gravity by using a hydrometer to find the state of charge. If the battery assembly is getting discharged frequently check the charging system. A. Save money (cheap cost) B. Save environment (No pollution) C. Save strength (less weight) A. The battery continuously charges with generator. B. But there is no guarantee for Vehicle to have a high speed Means (0 – 40 KMPH) with in 10 seconds. 72 V. C. 100 A battery takes more place so seat size will be reduced. D. It is complex to maintain electric two wheeler. The battery cost is major challenge for project and with newer chemistry development over the coming year we have decided to offer the battery on lease . Present model is commercially developed, will appeal the young generation to move to electric.