Professional Documents
Culture Documents
Telecommunication Systems 1: Prof. Dr. Tayfun Akgül
Telecommunication Systems 1: Prof. Dr. Tayfun Akgül
Examples
i. Motion, sound, picture, video, traffic light…
ii. Natural system (ecosystem), human-made system
(machines, computer storage system), abstract system
(traffic, computer programs), descriptive system (plans)
Signal Examples
• Electrical signals --- voltages and currents in a
circuit
• Acoustic signals --- audio or speech signals
(analog or digital)
• Video signals --- intensity variations in an image
(e.g. a CAT scan)
• Biological signals --- sequence of bases in a
gene
• Noise: unwanted signal
:
Measuring Signals
0.8
0.6
0.4
0.2
Amplitude
0
1 22 43 64 85 106 127 148 169 190 211 232 253 274 295 316 337 358 379 400 421 442 463 484 505 526 547 568 589 610 631 652 673 694 715
-0.2
-0.4
-0.6
-0.8
-1
Period
Definitions
• Voltage – the force which moves an electrical current
against resistance
Note the subtle use of parentheses and square brackets to distinguish between
CT and DT signals.
Analog Signals
• Human Voice – best example
• Ear recognises sounds 20KHz or less
• AM Radio – 535KHz to 1605KHz
• FM Radio – 88MHz to 108MHz
Digital signals
• Represented by Square Wave
• All data represented by binary values
• Single Binary Digit – Bit
• Transmission of contiguous group of bits is a bit
stream
• Not all decimal values can be represented by
binary
1 0 1 0 1 0 1 0
Analogue vs. Digital
Analogue Advantages
• Best suited for audio and video
• Consume less bandwidth
• Available world wide
• Less susceptible to noise
Digital Advantages
• Best for computer data
• Can be easily compressed
• Can be encrypted
• Equipment is more common and less expensive
• Can provide better clarity
Analog or Digital
• Analog Message: continuous in amplitude and over
time
– AM, FM for voice sound
– Traditional TV for analog video
– First generation cellular phone (analog mode)
– Record player
• Digital message: 0 or 1, or discrete value
– VCD, DVD
– 2G/3G cellular phone
– Data on your disk
– Your grade
• Digital age: why digital communication will prevail
A/D and D/A
• Analog to Digital conversion; Digital to
Analog conversion
– Gateway from the communication device to the
channel
• Nyquist Sampling theorem
– From time domain: If the highest frequency in the
signal is B Hz, the signal can be reconstructed
from its samples, taken at a rate not less than 2B
samples per second
A/D and D/A
• Quantization
– From amplitude domain
– N bit quantization, L intervals L=2N
– Usually 8 to 16 bits
– Error Performance: Signal to noise ratio
Real vs. Complex
Q. Why do we deal with complex signals?
A. They are often analytically simpler to deal with than real
signals, especially in digital communications.
Periodic vs. Aperiodic Signals
Periodic signals have the property that x(t + T) = x(t) for all t.
The smallest value of T that satisfies the definition is called the
period.
Shown below are an aperiodic signal (left) and a periodic signal
(right).
Causal vs. Non-causal
A causal signal is zero for t < 0 and an non-causal signal is
zero for t > 0
Social System
Genetic System
Info
Info Comm Info
Info
Source
Source System Sink
Sink
Block Diagram
Info
Info
Source
Source
m(t)
n(t)
message
noise
from
source
Transmitter Receiver
Channel
Tx s(t) r(t) Rx
transmitted received
signal signal m~ (t )
received
message
to
sink Info
Info
Sink
Sink
Telecommunication
• Telegraph
• Fixed line telephone
• Cable
• Wired networks
• Internet
• Fiber communications
• Communication bus inside computers to
communicate between CPU and memory
Wireless Comm Evolution:
UMTS (3G)
http://www.3g-generation.com/
http://www.nttdocomo.com/reports/010902_ir_presentation_january.pdf
Wireless Communications
• Satellite
• TV
• Cordless phone
• Cellular phone
• Wireless LAN, WIFI
• Wireless MAN, WIMAX
• Bluetooth
• Ultra Wide Band
• Wireless Laser
• Microwave
• GPS
• Ad hoc/Sensor Networks
Comm. Sys. Bock Diagram
Noise
m(t) Channel Rx ~ (t )
m
Tx
s(t) r(t)
Baseband Baseband
Bandpass
Signal Signal
• “Low” Frequencies Signal
• <20 kHz • “High” Frequencies
• Original data rate • >300 kHz
• Transmission data rate
Demodulation
Modulation or
Detection
f = 5 kHz
f = 300 kHz
There are also other reasons for going from baseband to bandpass
Another Classification of Signals
(Waveforms)
• Deterministic Signals: Can be modeled as a
completely specified function of time
Disadvantages
Susceptible to interference
Prone to damage during
installation
Distance limitations not
understood or followed
Glass Media
• Core of silica, extruded glass or plastic
• Single-mode is 0.06 of a micron in diameter
• Multimode = 0.5 microns
• Cladding can be Kevlar, fibreglass or even steel
• Outer coating made from fire-proof plastic
Advantages Disadvantages
Can be installed over long Most expensive media to
distances purchase and install
Provides large amounts of Rigorous guidelines for
bandwidth installation
Not susceptible to EMI RFI
Can not be easily tapped (secure)
Wireless
Wireless (2)
• Radio transmits at 10KHz to 1KHz
• Microwaves transmit at 1GHz to 500GHz
• Infrared transmits at 500GHz to 1THz
• Radio transmission may include:
– Narrow band
– High-powered
– Frequency hopping spread spectrum (the hop is controlled by
accurate timing)
– Direct-sequence-modulation spread spectrum (uses multiple
frequencies at the same time, transmitting data in ‘chips’ at high
speed)
Connectors
Fibre Optic
RJ45
Token Ring
Thicknet
T-Piece
The Bands
3KHz 30KHz 300KHz 3MHz 30MHz300MHz 3GHz 30GHz 300GHz 3THz
Submillimeter
Far
Range
ELF VLF LF MF HF VHF UHF SHF EHF Infra-
Red
Radio Optical
300m 1500nm
1PetaHz 1ExaHz
O Y B I V
Near R r e
G
r n i
a l l d o
Infra- e n l
e
u i l Ultraviolet X-Ray
g o e g e
Red d e w n e o t