Roll No.- 1900540100110 Section- CSE-32B Project – Ultrasonic Radar
Submitted to :- Submitted by:-
Mr. Anurag Shukla Piyush Chandra Rastogi • Introduction • Objective • About Sensors Presentation • Software
Outline • Future Scope
Introduction
• This is an advance RADAR system for
surveying the home . • It provide protection to the home by surveying all time. • This RADAR system is made by Arduino Board with sensor like Ultrasonic sensor and Servo motor . • To make this advance ,I use buzzer with LED light that can be easy to user or owner and can be aware from outsiders like thief etc. • Also , there is a graph on the screen by which owner can see the right position of the outsiders or unwanted things that comes under the RADAR . Objective
• The first thing is that I learnt
from the training of Internshala and I want to make this project advance at my level . • The main objective of this RADAR system is to provide security to the home , office etc. Arduino
• The Arduino is an open-source
electronics platform • A microcontroller • 14 Digital input and output pins • 6 Analog pins Radar Sensor & Components Used:- • Arduino Board • Arduino IDE • Processing Software • Servo Motor • Ultrasonic Sensor • Bread Board • Jumper Wires • USB-A USB-B USB Micro B USB-C Servo Motor
• Servo motors have three wires: power,
ground, and signal. • The power wire is typically red . • The signal pin is typically yellow, orange or white. • The third pin of the servo connector carries the control signal, used to tell the motor where to go. Ultrasonic Sensor • Measures the distance to an object using ultrasonic sound waves. • The HC-SR04 ultrasonic sensor uses SONAR to determine the distance of an object just like the bats do. • The configuration pin of HC-SR04 is VCC (1), TRIG (2), ECHO (3), and GND (4). • The supply voltage of VCC is +5V and you can attach TRIG and ECHO pin to any Digital I/O in your Arduino Board Bread Board
• A breadboard is a rectangular plastic
board with a bunch of tiny holes in it. • It doesn’t require soldering to connect the components on board. • The connections are not permanent. • So, it is easy to remove a component if you make a mistake. Software Used
• Arduino IDE contains-
• Text editor for writing code • A graphic window(serial monitor) • A toolbar with buttons for compiling code. • Also ,it connects to the Arduino hardware to upload programs and communicate with them . Processing Software • An IDE built for electronics art , new media arts and visual design. • Include text editor , compiler and a display window. • Can draw 2D and 3D graphics. • Libraries and tools available. Circuit Diagram Future Scope
• This project will help us a lot to
understand the RADAR being used in aircraft, ships, spacecraft, guided missiles, motor vehicles, weather formations, and terrain. • Due to easy distance calculation of the surroundings , this project can contribute largely and efficiently in many future endeavours.