Performance Standards IMO resolution The ECDIS must meet the performance standards of the IMO resolution (Maritime Safety Circular) MSC 232 (82) adopted on December 5, 2006. These standards highlight the following points:
The function of an ECDIS is primarily safe navigation and for the
purpose, it must be able to display all necessary information. This information display must be approved by the authority of the government or government-authorized hydrographic office. This would mean that information display must comply with the performance standards of the ECDIS and the display standards of the International Hydrographic Organization (IHO) document The ECDIS must enable charts to be updated in a simple and reliable manner. The charts in the ECDIS should be designed such that the navigational workload of the seafarer is reduced. The ECDIS should have the same reliability and presentation capabilities of paper chart. The ECDIS equipment should be capable of providing alerts in the event of equipment malfunction or improper display information. It should be able to distinguish between the ECDIS and the ENC, explain the system electronic navigational chart (SENC). The user should be able to select the preferred display among the three display presentation modes available in the ECDIS, namely, the standard display, base display, and all other information. The requirements of the display of SENC information are highlighted The requirements related to the provision and updating of chart information are highlighted. There must be scale indicator. There must be provisions in relation to the display of other navigational information such as common reference system and radar. The requirements in relation to radar information must be overlaid onto an ECDIS The display modes required in an ECDIS The use of standardized symbols and colors are recommended by the IHO. (The symbols will vary depending on the scale of the chart in use.) IHO S-52 standard). The display requirements of an ECDIS display. Requirements in relation to route monitoring and route planning. Requirements in relation to voyage recording.\requirements in relation to calculation accuracy (e.g. bearing and range measurements) Requirements in relation to sensor input (log, position fixing, etc.) . Requirements in relation to performance tests of malfunction alarms, and indications. Backup arrangements. Thepower supply (the main ECDIS to be connected to the main and emergency power sources, while the backup ECDIS must have a separate power source)