Professional Documents
Culture Documents
Team
Charan - 23PJ057
Presented By :
K. Sai Charan
19BES7029
ABOUT EFFTRONICS SYSTEMS PVT LTD.
2
TIME LINE CHART
How we’ll scale in the future
3
The Projects I was involved in
RDPM
RDPM codes Configurations with keil
Ac/Dc current sensors calibrations
Battery Health Monitoring units
Currents and voltages calibrations for rdpm
4
How Remote Diagnostic
& Predictive Maintenance
System works?
•Sensing health parameters of equipment.
•Communicating health data to central
location.
•Analyzing health data to provide actionable
decisions.
•Dissemination of actionable decisions to all
concerned.
5
Remote Condition Monitoring Solutions
6
Block diagram of rdpm
The main part of the rdpm is sel which is also known as cpu card the card consists of 8 ports which each port
connects to individuals like port 1 to ac currents, port 2 to dc currents and voltages.
Like that all the 8 ports will connect 8 different interfaces and the one out put port which connect to rui.
Rui is a unit which looks like a keypad interface in that we can note and see the values while the connection ready
In this total rdpm setup we connect current sensors both ac dc
And voltages also
Methods and knowledge improvement
When we buy a product then we have to modify it by our need i.e similarly called as we are doing calibrations to
current sensors
Calibration is a very main thing which done by the electrical objects like
Example : multimeter, load, fluke meter
Before we used in our college ece labs i have learnt a lot in ac/dc current sensors calibrations and to know the
variance.
formula = a2-a1/range *100
Like this variance found in sensors and it must be less than 1 if it exceeds then we must consider it as not useable we
have to recalibrate it again
8
Observation and work done
The part of mine in these as a testing team person before the product delivery to the customer the person give a set of
instructions with certain number of testcases I want to check and tell the report of the testcases where its pass/fail
If its pass ok other vise again rework will be done on tha same thing
Like shown below
10
CONCLUSION
• All the knowledge I gained from my college and professors helped me to serve in this
industry which are known as basics like keil software and tools in ece labs etc.
• Currents, voltages, processors, controllers and debugging calibrations configurations.
• These are the things I learnt here and I hope to improve my knowledge better in future .
11
ANY
DOUBT’S ?
12
Thank you
K. SAI CHARAN
23PJ057
23pj057@efftronics.com
https://www.efftronics.com
13