You are on page 1of 1

Technical Bulletin

Model: Kir-C2 Subject: Optional Heater operation From: 1st Tech. Support Sec. Service Support Dept. Classification:
Troubleshooting Mechanical Paper path Product Safety Part information Electrical Transmit/receive Other ( )

PAGE: 1/1 No.: RB121035

Date: 10-Oct-06

Prepared by: Hiromoto Saitoh


Action required Service manual revision Retrofit information

Important Note on the Optional Heaters for the Model K-C Series
The following optional tray heaters turn ON or OFF depending on the operation mode of the machine: Anti-condensation heater Tray heaters for mainframe Tray heaters for optional paper feed units

Operation Mode: While printing or in the Ready Condition Low Power Mode Transit Mode Night/Off Mode While the main switch is OFF, but the power cord is connected. While the power cord is disconnected.

Operation Panel: On Off Off Off Off Off

Engine: On On On Off Off Off

Optional Heater: Off Off Off On On Off

You might also like