Professional Documents
Culture Documents
Sample PGTP 2011
Sample PGTP 2011
l
R =
31. A 200 watt 230 volt lamp is connected across 115 volt supply. The lamp will draw power
A) 200 W
B) 100 W
C) 50 W
D) 25 W
32. The number of 2F, 400 V capacitors needed to obtain a capacitance value of 1.5 F rated for 1600 V is
A) 12
B) 8
C) 6
D) 4
33. A parallel plate air capacitor has plates of 1500 cm2 separated by 5mm. If a layer of dielectric 2 mm thick and
relative permittivity 3 is now introduced between the plates, then the new separation in mm between the plates, so
that the capacitance value is unchanged, will be
A) 7.0
v
in
B) 6.33
C) 5.67
R
L
v
AK
D) 5.00
34. In the given SCR circuit if the firing angle is decreased from 90 to 0 degrees,
average power delivered to the load :
A) Will decrease
B) Will Increase
C) Remains constant I
G
D) First increase then decrease
35. A salient pole synchronous motor is running on noload. If its excitation is made off, it will
A) Continue running at synchronous speed.
B) Continue running but at a speed slightly less then synchronous one.
C) Continue running at speed more than synchronous speed
D) Stop
Code: XXXX-XX-XXXX Page 4 of 7
Name: __________________________Registration No._______________________ Signature ___________________
Civil
36. The main constituent of a Portland cement is:
A) Alumina
B) Lime
C) Silica
D) Gypsum
37. Wrought Iron is used for:
A) Structural work in Beam
B) Small sized water pipes
C) Columns & Struts
D) None of all above
38. The ratio of Volume of voids to the volume of soil is termed as:
A) Density
B) Porosity
C) Specific Gravity
D) Permeability
39. A branch of surveying in which the horizontal and vertical distances of a point are obtained by instrumental
observations is known as:
A) Chain Surveying
B) Tacheometric Surveying
C) Plain Table Surveying
D) Hydrographic Surveying
40. Moment of inertia of a rectangle (width 'b' & height 'h') about its centroidal x-axis, is:
A) bh/3
B) bh/6
C) bh/12
D) bh/12
Chemical
41. Cavitation can be prevented by
A) Suitably designing the pump
B) Maintaining the suction head sufficiently greater than the vapor pressure
C) Maintaining suction head=developed head
D) By increasing the temperature of the liquid
42. How much O2 can be obtained from 90 kg of water
A) 32kg
B) 80kg
C) 64kg
D) 90kg
43. Use of baffles in agitators help in minimizing .. tendency
A) Swirling
B) Vortexing
C) Both A) & B)
D) Baffles are not used in agitators
44. A unit process is exemplified by
A) Distillation
B) Hydrogenation of oils
C) Absorption
D) Humidification
45. Dry ice (solidified CO2) is used for the
A) Storage and shipment of frozen foods and ice-creams
B) Liquefaction of permanent gases
C) For artificial rain
D) Both A) & C)
Mechanical
Code: XXXX-XX-XXXX Page 5 of 7
Name: __________________________Registration No._______________________ Signature ___________________
46. The velocity of a fluid particle at the centre of the pipe section is
A) Maximum
B) Minimum
C) Average
D) r.m.s
47. A 2 cm dia pipe transports water at 20m/s. If it exits out 100 small 2mm dia holes, the existing velocity, in m/s will
be
A) 120
B) 80
C) 40
D) 20
48. Tensile stress is
A) Stress due to any force
B) Stress due to change in length under a load
C) Stress caused by varying load
D) Stress measured by the ratio of the increase or decrease in length of the unloaded piece under tensile
force
49. If a cantilever beam of diameter D, cross section A, length L is subjected to uniformly distributed load W, it will
have maximum bending moment equal to
A) WL2/2
B) WLA/2
C) WL/2A
D) WL/2
50. A particle is moving in simple harmonic motion in a simple pendulum with some period of oscillation. Now in
order to double the period of oscillation
A) The mass of the bob should be doubled
B) The mass of the bob should be halved
C) The length of pendulum should be doubled
D) The length of pendulum should be quadrupled
Chemistry
51. If a salt bridge is removed between the two half cells, the voltage
A) Drops to zero
B) Does not change
C) Increases gradually
D) Increases rapidly
52. A cell constant is generally found by measuring the conductivity of aqueous solution of
A) BaCl2
B) KCl
C) NaCl
D) MgCl2
53. Oleum is
A) Castor oil
B) Oil of vitriol
C) Fuming of H2SO4
D) none of the above
54. Which is the most volatile compound?
A) HI
B) HCl
C) HBr
D) HF
55. Chlorine acts as a bleaching agent only in the presence of
A) Dry air
B) Moisture
C) Sun light
D) None of the above
Computer
Code: XXXX-XX-XXXX Page 6 of 7
56. Which of the following have not external fragmentation problem
A) paging
B) segmentation
C) MFT
D) None of the above
57. Which of the following gate is two-level logic gate
A) OR gate
B) AND gate
C) NAND gate
D) NOT gate
58. What layer of the OSI model does data compression
A) Network
B) Data link
C) Presentation
D) Physical
E)
59. The ability of interpret a message using its own methods is called
A) Polymorphism
B) Encapsulation
C) inheritance
D) message
E)
60. In the set of integers, a relation R is defined as aRb, if and only if b=|a|. This relation is
A) Reflexive
B) Irreflexive
C) Symmetric
D) Anti-symmetric
Code: XXXX-XX-XXXX Page 7 of 7