You are on page 1of 4

Page 1 of 4

Corrections to First Printing


Preface, Chapters 1 -5
FUNDAMENTALS OF HEAT AND MASS TRANSFER 5th
And
INTRODUCTION TO HEAT TRANSFR 4th
Page

Correction

vii

3rd line from top. Change cap F to cap E

xix

Do not indent saturated vapor conditions

17

Top page header word "energy" should read "Energy"

18

& should appear as E& st ; i.e., the st is subscripted


Est

23

Part 2. of Comments. Put period after 40 W/m2 K and delete rest of sentence

36

Problem1.17. Change T to Ts

42

Problem 1.46, 5th line from the top. Italicize h

45

Problem1.64, part (b), 4th line. Replace < with

52

Section 2.1, 5th line. Add comma after example

63

Third line after Eq. (2.14). Add the word net (in italics)

74

Problem 2.6. Replace subscript 0 by o in k = ko + aT

75

Problem 2.13, 3rd line of part (b). Insert comma after q& = q&o exp - ax

77

Problem 2.25, part (g), 2nd line. Replace period by question mark
Problem 2.26, 4th line from bottom of page. Replace 0 by o in To

78

Problem 2.27, 11th line. Replace Greek by a

79

Problem 2.30, part (b), 4th line. Italicize h in 10 h 100


Problem 2.31, 8th line. Superscript instead of subscript in W/m2

80

Problem 2.40, 8th line. Replace r by z in last term of equation. I..e. +dz 2

Page 2 of 4

Page

Correction

85

Problem 2.54, part (a), 5th line. Replace cap T by lower case t in parenthesis. I.e.
T(r,t)

99

Sixth line of part 3. Add subscript lower case oh to h. I.e., ho

L
OP
1
M100 +
N b0.9 + 0.34 + 100g 10 Q

100

Middle of page. Insert + sign. I.e.,

103

Fifth line of part 1. Replace cap W by lower case w.

112

Schematic after 2nd line of part 1. Replace subscript 1 by subscript t (two places)
Third line from bottom. Italicize h in hfg

119

On the schematic. Reverse the direction of the arrow. Delete the extraneous
double prime. Add the subscript B to Rcond,B

120

On the second figure, change h=2000 W/m2 K to h=1000 W/m2 K

125

The three curves in the graph associated with Comment 2 are in error. Corrections
are attached to page 125.

141

Schematic corresponding to Eq.(3.94). Shading is missing on top portion of base.


In Eq.(3.91), replace r2 by r2c on the right-hand-side of the equation for C2 .

148

Fifth line from top. Add parenthesis and superscript . I.e.,

F hP IJ
m=G
H kA K

1/ 2

=.........

Do not italicize cap kay.


156

Problem 3.19, second line above part (a). Insert comma after gap.

172

Problem 3.108, part (a), 2nd line. Replace identity with identify.

173

Problem 3.110, part (a), last line. Replace 3.2 by 3.4.

178

Problem 3.132. Line directly above schematic. Add /W to expression for Rt,c .
I.e., Rt,c = 2 106 m 2 K / W .

Page 3 of 4

Page

Correction
2

198

Equation 4.31; denominator of RHS should have exponent "two"; i.e. (x)

201

Table 4.2, Equation 4.33; equation number in parenthesis should be properly


aligned

205

Figure 4.8; close up between subscripts on the term cap R double-prime


subscript lc tea comma lc sea

213

Comment 5, 7th line; insert hyphen for "pre-processing" and "post-processing"

215

Example 4.4, Schematic; close up between subscripts on T sub infinity comma lc


oh and T sub infinity comma lc eye

216

Ninth line; the term T18 should be located on the right-hand side of the term in
parenthesis instead of the left-hand side.

216

Middle of page; tabulated values for T3 - T6 ; insert space after number and K unit.

221

Problem 4.11; illustration is clipped on RHS

226

Problem 4.40; illustration; convection cloud, lower surface should read h sub ital
lc ell instead of h sub ital lc eye

228

Problem 4.48, 4th line; "106" should read as "10 "

234

Problem 4.74; illustration is clipped on RHS

234

Problem 4.75; illustration is clipped on LHS

235

Problem 4.77; illustration is clipped on LHS and RHS

237

Problem 4.80(c), 7th line; delete comma between length and L

238

Problem 4.83, 7th line; should read as . platen is insulated instead of


. platens insulated.

250

Example 5.2, Section 2, 7th line; should read as T(4.9 s) instead of T(5.2 s)

260

Equation 5.47b; subscript on J sub lc oh should be a "zero"

266

Mid-page, equation "t sub a ="; "cap T sub theta" should read "cap T sub infinity"

267

Mid-page, equation; insert "equals sign" between "T(ro )" and "20C"

Page 4 of 4

Page

Correction

278

Sixth line from bottom; the number "1.307" should read as "1.307 rad"

292

Section 2, 8th line; capitalize "Equation"

301

Problem 5.19(a), 11th line; the term "Ass " should read as "As "

317

Problem 5.105, highlight problem number (computer-based solution required)

318

Problem 5.106, highlight problem number (computer-based solution required)

318

Problem 5.107, highlight part (c) only (computer-based solution required)

322

Problem 5.120, highlight problem number (computer-based solution required)

323

Problem 5.124, highlight problem number (computer-based solution required)

323

Problem 5.125, highlight problem number (computer-based solution required)

323

Problem 5.126, highlight problem number (computer-based solution required)

323

Problem 5.127, highlight problem number (computer-based solution required)

323

Problem 5.128, highlight problem number (computer-based solution required)

324

Problem 5.129, highlight problem number (computer-based solution required)

October 8, 2001

You might also like