Professional Documents
Culture Documents
DYNAMICS OF STRUCTURES
6
5
4
3
2
1
0
0.05
0.10
0.15
Damping ratio
0.20
FIGURE 2-13
Damping ratio vs. number of cycles required to
reduce peak amplitude by 50 percent.
For lightly damped systems, greater accuracy in evaluating the damping ratio
can be obtained by considering response peaks which are several cycles apart, say m
cycles; then
2m
vn
=
(2-58)
ln
vn+m
1 2
which can be simplied for low damping to an approximate relation equivalent to
Eq. (2-57):
. vn vn+m
(2-59)
=
2 m vn+m
When damped free vibrations are observed experimentally, a convenient method
for estimating the damping ratio is to count the number of cycles required to give a 50
percent reduction in amplitude. The relationship to be used in this case is presented
graphically in Fig. 2-13. As a quick rule of thumb, it is convenient to remember that for
percentages of critical damping equal to 10, 5, and 2.5, the corresponding amplitudes
are reduced by 50 percent in approximately one, two, and four cycles, respectively.
Example E2-1.
A one-story building is idealized as a rigid girder supported by weightless columns, as shown in Fig. E2-1. In order to evaluate the
dynamic properties of this structure, a free-vibration test is made, in which the
roof system (rigid girder) is displaced laterally by a hydraulic jack and then
suddenly released. During the jacking operation, it is observed that a force of
20 kips [9, 072 kg] is required to displace the girder 0.20 in [0.508 cm]. After
the instantaneous release of this initial displacement, the maximum displacement on the rst return swing is only 0.16 in [0.406 cm] and the period of this
displacement cycle is T = 1.40 sec.
From these data, the following dynamic behavioral properties are determined:
Weight W = mg
31
v
p = jacking force
FIGURE E2-1
Vibration test of a simple building.
W
= 1.40 sec
gk
Hence
W =
1.40 2
2
g k = 0.0496
20
386 = 1, 920 kips [870.9 103 kg]
0.2
1
1
=
= 0.714 Hz
T
1.40
= 2f = 4.48 rad/sec
(3) Damping properties:
Logarithmic decrement: = ln
0.20
= 0.223
0.16
Damping ratio:
.
= 3.55%
=
2
Damping coefcient:
c = cc = 2m = 0.0355
Damped frequency:
2(1, 920)
4.48
386
= 1.584 kips sec/in [282.9 kg sec/cm]
.
D = 1 2 = (0.999)1/2 =
v 6
1
v0
v0 =
4 6
5