Professional Documents
Culture Documents
3-D Beaded Daffodils: This Content Created by Emily Hackbarth
3-D Beaded Daffodils: This Content Created by Emily Hackbarth
These 3-D beaded flowers work up to be around an inch across and I think they
would make really neat post earrings. I'm sure you can think of some additional uses
as well. You will need to be familiar with both flat and tubular brick stitch to follow
these directions successfully.
What
First we will make the bell in the center of the flower. Using yellow nymo, make a
base row of 12 yellow beads and add one more row of 12.
On the third row we need to start decreasing to form the bell shape. Add the first 3
beads in the row normally. Then do a decrease stitch by picking up a bead, skipping
the 4th thread in the row below and going under the 5th one. Go back up through
the bead you added. Add two more beads normally, then a decrease stitch, then add
2 more beads normally. Close up the row skipping the last thread in the previous
row. This acts as a third decrease. You should end up with 9 beads in this row.
In the 4th row we also have 3 decreases but since we start with only 9 beads and
want to get down to six, every other stitch is a decrease stitch. So start with two
beads, go under the third thread and back up through the second bead you added.
Add one normal stitch, one decrease, one normal, one decrease and close the row.
Weave your thread into the work to secure it and snip.
Now we'll start adding petals. Thread your needle with white thread and weave it into
the work to secure. Then weave up and out of one of the beads in the six bead row
you just completed. Pick up two white beads and go back down through the yellow
bead your thread is coming out of. Then go up through one of the white beads you
added. This forms a 2 bead base row to begin your petal. Increase in the next row to
3, then to 4 and then 5. Then decrease back to two.
Pick up one more bead and go through the bead in the previous row that your thread
is not coming out of. Continue down through the beads along the edge of the petal,
up through the beads in the opposite edge, through the point bead and down
through the first side again. Pull the thread tight, and it should cause the petal to cup
up into the 3D petal shape. Go down through the yellow bead your petal is attached
to and up through the one next to it to get into position to add your next petal.
Once you have added a petal to each of the six yellow beads it's time to connect
Finally, to add a pistil, go down through the yellow bead at the base of your last petal
so that your thread is going through the hole in the center of the flower. Pick up 4
yellow beads, skip one and go back through the other 3. Then go through the yellow
base bead opposite of the one you left. Weave your thread into the work to secure
and snip.