Professional Documents
Culture Documents
SRF05 - Ultra-Sonic Ranger: Technical Specification
SRF05 - Ultra-Sonic Ranger: Technical Specification
Page 1 of 4
Introduction
The SRF05 is an evolutionary step from the SRF04, and has been designed to increase flexibility, increase
range, and to reduce costs still further. As such, the SRF05 is fully compatible with the SRF04. Range is
increased from 3 meters to 4 meters. A new operating mode (tying the mode pin to ground) allows the SRF05
to use a single pin for both trigger and echo, thereby saving valuable pins on your controller. When the mode
pin is left unconnected, the SRF05 operates with separate trigger and echo pins, like the SRF04. The SRF05
includes a small delay before the echo pulse to give slower controllers such as the Basic Stamp and Picaxe
time to execute their pulse in commands.
Mode 1 - SRF04 compatible - Separate Trigger and Echo
This mode uses separate trigger and echo pins, and is the simplest mode to use. All code examples for the
SRF04 will work for the SRF05 in this mode. To use this mode, just leave the mode pin unconnected - the
SRF05 has an internal pull up resistor on this pin.
Page 2 of 4
www.DataSheet4U.com
Page 3 of 4
www.DataSheet4U.com
To use mode 2 with the Basic Stamp BS2, you simply use PULSOUT and PULSIN on the same pin, like this:
SRF05 PIN 15
Range VAR Word
SRF05 = 0
PULSOUT SRF05, 5
PULSIN SRF05, 1, Range
Range = Range/29
'
'
'
'
Page 4 of 4
www.DataSheet4U.com