Experiment no 1: Study of Microwave Components and Instruments
Objective: To become familiar with microwave components and instruments available in the laboratory.
Experiment no 2: Reflex Klystron Characteristics
Objective: To study mode characteristics of reflex klystron and hence to determine mode number, transit time, electronic tuning ranges (ETR) and electronic tuning sensitivity (ETS).
Experiment no 3: Frequency Measurement
Objective: To examine the frequency characteristics of klystrons and also to become familiar with typical microwave frequency measurements.
Experiment no 4: Measuring VSWR
Objective: To become familiar with the basic technique for measuring voltage standing wave ratio.
Experiment no 5: Attenuation Characteristics
Objective: To study the attenuation characteristics of a variable attenuator.
Experiment no 6: Study of Gunn Oscillator
Objective: To study I-V Characteristics of Gunn Diode.
Experiment no 7: Properties of Directional Coupler
Objective: To measure coupling factor, directivity and insertion loss of a directional coupler.
Experiment no 8: Study of Power Division in Magic Tee
Objective: To measure isolation between E and H arms of the magic tee & Demonstrate 3dB power division in the side arm of the magic tee.
Experiment no 9: Circulator Characteristics
Objective: To study operation of ferrite circulator and hence measure insertion loss and isolation offered by this device.
Experiment no 10: Horn Antenna Characteristics
Objective: To obtain the radiation pattern of a Horn antenna.
Dhanalakshmi Srinivasan Engineering College, Perambalur Department of Mechanical Engineering Me8097 / Non-Destructive Testing and Evaluation Question Bank - 2 Marks & 16 Marks