Professional Documents
Culture Documents
Dosing Pots
Dosing Pots
Dosing Pots
Cost-effective dosing
Easy installation and maintenance
Supplied fully assembled
Simple operation
Sizing
Installation
It is important to ensure that the unit is correctly installed to give rapid and safe dispersal of the chemical dose. Ideally
the unit should be installed where there is a high differential pressure between the flow and return pipework.
The unit should be securely fixed to a wall by the integral wall mounting bracket. Ensure a suitable drainage point is provided
for the unit.
The BSS Group plc and its subsidiary companies assume that the user will take all necessary steps to ensure that all products purchased are suitable
for the conditions in which they were intended to operate.
Every effort has been made to ensure that the information contained in this publication is accurate at the time of publishing but all illustrations and
descriptions are intended to provide an approximation only and are not subject to contractual liability.
The BSS Group plc and its subsidiary companies expressly exclude all liability for typographical errors or omissions or for any misinterpretation of the
information provided in this publication. All products are subject to alteration without notice.
Dosing Pots
Style 08_1b Section Right Page
Operation
1
2
3
4
5
6
7
Tundish
B
Air vent
38" BSP
A
Fill Valve
1" BSP
C
Return Valve
1" BSP
Repeat as required to supply the system with the correct volume of dosing chemical.
E
Drain Valve
1" BSP
Technical information
21 bar
120C
-10C
Materials of construction
Pot, funnel, brackets, pipes
Valves
Finish
G
490
490
490
490
490
590
590
590
Nominal Maximun
Weight Pressure (bar)
9kg
10
11.5kg
10
16.5kg
10
23.5kg
10
29.5kg
8
40.5kg
5
45.5kg
5
55.5kg
4
Product
Code
52209992
52210006
52210017
52210028
52210039
52210061
52210072
52210083
Approvals
97/23/EC Article 3 Paragraph 3 Sound
Engineering Practice.
Welded to BS EN 287
Mild steel
Forged brass with PTFE seats
Powder coated red
G
D
4 x 10mm
holes
Technical data
Test pressure
Maximum temperature
Minimum temperature
F
310
310
310
310
310
410
410
410
150mm
Dimension mm
C
D
E
80 200 250
120 200 250
270 200 250
420 200 250
650 200 250
350 300 350
450 300 350
570 300 350
B
180
290
440
590
820
560
620
720
260mm
A
620
730
880
1030
1260
1000
1060
1160
Capacity
litres
3.5
6
11
18
25
35
40
50
D
Flow Valve
1" BSP
E
F
The BSS range of water treatment products protect heating and cooling
systems for corrosion, sludge and limescale. For dosage rates refer to
manufacturers literature.
Registered Office: The BSS Group plc, Fleet House, Lee Circle, Leicester LE1 3QQ, England. Registered No. 60987
BSSDOSING/0609/4