Professional Documents
Culture Documents
2g Bts Abis Over Ip Configuration
2g Bts Abis Over Ip Configuration
Plug the USB flash drive into the USB port of the computer.
Create a folder named BTS3900 GSM in the USB flash
drive.
create a folder named Site0 (the name is the site name ) in
the folder BTS3900 GSM.
Copy the TransCfg.ini file to the folder ,you can get the
TransCfg.ini file from the BSC integration Team.
Check the status of the GBTS, make sure the GTMU board is
power on and working normal.
Put the USB flash into the USB port of the GTMU.
Do not remove the USB flash drive during the period from
plugging in the flash drive to the duration of normal
operation of the base station. Otherwise, the file load fails.
Check with BSC integration team whether the BSC can Ping
to the BTS IP.
In this dialog box, set the IP addresses of the BTS and BSC and
other related parameters step by step like below, the parameters
in the red box are the same to all the sites, the parameters in the
yellow box are different to different sites.
Click Config Para to complete the settings of the IP addresses
and VLAN parameters.
Click the Config Router tab. On the Config Router tab page, set
the route of the BTS, as shown in the below snapshot.
one goes to BSC DEVIP, other one goes to IPCLK1,the last one
goes to IPCLK2.
Add the router to BSC like below:
Click the Query tab. On the Query tab page, click Query to query
the static IP addresses
Make sure all the parameters are correct according to the IP
design.
After the site reset, you should contact the BSC integration team
and check whether they can PING to the BTS IP, if the site is UP,
you can see the board is OK.
If the site is UP, also you should check with the BSC integration
Team whether there are any alarms in the BTS and Clear all the
alarms.
Bilal Ahmad
b80010275
Cell # 0530599207