Professional Documents
Culture Documents
STANEX diaphragm
6
1
4
8
1 Stationary inlet
2 Mill shell with welded-in slide rings and
flange for girth gear
3 Slide shoe bearing
4 STANEX diaphragm with adjustable lifters
5 Outlet grate with adjustable lifters
6 Lining of coarse grinding compartment
7 Lining of fine grinding compartment
8 Girth gear with gear guard
Mill body
The mill body consists of an all-welded
mill shell and a T-sectional welded-up
slide ring at either end, the cylindrical
part of which is welded onto the ends
of the shell. Side-driven mills have a
reinforced shell section with a flange
for bolting on the girth gear. Centrally
driven mills have an outlet cone with
large openings for material and venting
air. The large diameter of this cone is
welded onto the cylindrical part of
the outlet slide ring, while the small
diameter of the cone has a flange for
bolting on the coupling of the central
drive. The mill shell has four manholes,
two for each grinding compartment.
LGD gear
Mill diameter
Mill diameter
1 Inlet
2 Outlet casing
3 Slide shoe bearing
4 Main gearbox
5 Mill motor
6 Auxiliary drive
Mill length
Mill
Size (DxL)
Speed (rpm)
Gear size
Installed motor
power (kW)
LGD
3.8x13
16.86
2570
18
4.2x12.5
16.03
3130
18
4.2x14.5
16.03
3660
18
4.6x13.5
15.33
4205
32
4.6x14.5
15.33
4535
32
4.6x15.5
15.33
4870
32
5.0x14
14.69
5345
32
5.0x15
14.69
5750
50
5.0x16.5
14.69
6355
50
5.4x15
14.13
6985
50
5.4x16.5
14.13
7725
50
5.8x15.5
13.62
8680
80
5.8x17
13.62
9560
80
*)
Copyright 2010 FLSmidth A/S. ALL RIGHTS RESERVED. FLSmidth is a (registered) trademark of FLSmidth A/S. This brochure makes no offers, representations
or warranties (express or implied), and information and data contained in this brochure are for general reference only and may change at any time.
www.flsmidth.com
C 11-10 300-1-ENG
Motor*)