Professional Documents
Culture Documents
1/2
Description:
Recommended use:
As a filler for repairing cracks, damages and blowholes in concrete and steel surfaces.
The product is easy to work with and can be applied in thick coats (above 5 mm).
Meets FDA requirements.
Availability:
PHYSICAL CONSTANTS:
Colours/Shade nos:
Finish:
Volume solids, %:
Flash point:
Specific gravity:
Dry to touch:
Fully cured:
Pastel blue/3010S
Semi-gloss
100
Non-flammable
1.6 kg/litre - 13.3 lbs/US gallon
2-3 hours at 20C/68F
7 days at 20C/68F
The physical constants stated are nominal data according to the HEMPEL Group's approved formulas. They are
subject to normal manufacturing tolerances and where stated, being standard deviation according to ISO 3534-1.
APPLICATION DETAILS:
Mixing ratio for 355SA:
Application method:
Thinner (max.vol.):
Pot life:
Cleaning of tools:
Recoat interval, min:
Recoat interval, max:
Safety:
Handle with care. Before and during use, observe all safety labels on packaging and
paint containers, consult HEMPEL Material Safety Data Sheets and follow all local or
national safety regulations. Avoid inhalation, avoid contact with skin and eyes, and do
not swallow. Take precautions against possible risks of fire or explosions as well as
protection of the environment. Apply only in well ventilated areas.
Page 1 of 2
HEMPEL
Product Data Sheet
2/2
The surface must be sound and free from dust, loose paint, oil/grease and other contaminants.
Metal: Remove oil and grease, etc. with suitable detergent. Remove salt and other contaminants
by (high pressure) fresh water cleaning. Abrasive blasting, power tool cleaning or sanding,
depending on material and condition of the surface. Finally clean the area with HEMPELS THINNER
08450. Priming after abrasive blast cleaning, but prior to filling, can be done with a thin layer of
e.g. HEMPADUR 15590.
Concrete: Remove slip agent and other possible contaminants by emulsion washing followed by
high pressure hosing with fresh water. Remove scum layer and loose matter to a hard, rough and
uniform surface, preferably by abrasive blasting, possibly by other mechanical treatment or acid
etching. Seal surface with suitable sealer, e.g. HEMPADUR SEALER 05990, prior to filling.
APPLICATION
CONDITIONS:
Use only where application and curing can proceed at temperatures above 5C/41F.
The temperature of the substrate should also be above this limit.
Apply only on a dry and clean surface with a temperature above the dew point to avoid
condensation.
PRECEDING
COAT:
SUBSEQUENT
COAT:
According to specification.
REMARKS:
Note:
Mix and stir the two components thoroughly until an even colour is achieved, whereafter the filler is
ready for use. Do not mix more than is necessary for use within the pot life.
If the maximum recoating interval is exceeded, roughening of the surface is necessary to ensure
intercoat adhesion.
May be sanded after 20 hours (20C/68F).
HEMPELS EPOXY KNIFING FILLER 355SA is for professional use only.
ISSUED BY:
Page 2 of 2