Professional Documents
Culture Documents
physical lab.
1
Year Level
st
Objective
The purpose of this experiment is to determine the natural frequency of a
cantilever beam andstudy both undamped and damped free vibration motion of a
cantilever beam.
Introduction:
For a cantilever beam subjected to free vibration, and the system is
considered as continuous system in which the beam mass is considered
as distributed along with the stiffness of the Measurements of thin film
properties are difficult when compared to bulk materials. One method
for finding the modulus of elasticity of a thin film is from frequency
analysis of a cantilever beam. A straight, horizontal cantilever beam
under a vertical load will deform into a curve. When this force is
removed, the beam will return to its original shape; however, its inertia
will keep the beam in motion. Thus, the beam will vibrate at its
characteristic frequencies. If a thin film is sputtered onto the beam, the
flexural rigidity will be altered. This change causes the frequency of
vibrations to shift. If the frequency shift is measured, the films elastic
modulus can be calculated.
Procedure:
1. Suspend the steel ruler on the table with 0.4 m
freestanding
2. Vibrate the free end and measure the time for 20
vibration
3. Repeat the measurement with 0.5 & 0.6 & 0.7 and
0.8
4. Save your result in the table
2
4
5. Find the slope and put T on the Y=axis and L on
the x axis
6. Use this equation to calculate Young modulus
P
1
(
)
2 2
slope
4 d
That the thickness of the ruler is d=0.001 and the density of the
steel is p=8000 kg/
m3
Questions:
tensile stress
tensile strain
F
A
e
l
m2
= kg/m.
s2