Professional Documents
Culture Documents
Loading Ericsson GPEH Files Into ANALYZER Tech Notes PDF
Loading Ericsson GPEH Files Into ANALYZER Tech Notes PDF
GPEH files
Technical Notes
March 2009
www.actix.com
The content of this manual is provided for information only, is subject to change without
notice, and should not be construed as a commitment by Actix. Actix assumes no
responsibility or liability for any errors or inaccuracies that appear in this documentation.
Copyright Actix 2009. All rights reserved. All trademarks are hereby acknowledged.
www.actix.com
Actix Analyzer Loading Ericsson GPEH files March 2009 Technical Notes
Full mode loads all messages in the data but can be slow, and may fail, depending on the
amount of data selected for the load. If you are running Analyzer on a PC with good
performance and have less than 200MB of data, you might prefer this option.
Minimal mode allows you to load a selected subset of the overall data, through the
selection of Scenarios or load-time queries. If you have more than 200MB of data and are
running Analyzer on a PC with a low performance, you might prefer this option.
If the amount of data is too high, the load will eventually
fail with a file is corrupted message.
www.actix.com
Actix Analyzer Loading Ericsson GPEH files March 2009 Technical Notes
Further down in the Change Preferences dialog, note the box named Ericsson > Load all
adjacent files:
With Ericsson GPEH files, you only need to select the *.Mp0 file in a particular folder, and
Analyzer will automatically load the corresponding session files in that folder (all other files
with the same name ending in Mp1 onwards (*.Mp1, *.Mp2, *.Mp3 ), as shown below:
Normally, if you load the first *.Mp0 file in the folder, ALL corresponding files for ALL
sessions will be loaded (including all other *.Mp0 files). This may cause problems if your
PC is unable to process large amounts of data (possibly 200MB or more).
If you would like to load only 1 session, as shown in the screenshot above, clear the Load
all adjacent files box.
Note that even with the load adjacent option deselected,
you can still select multiple *.Mp0 files.
www.actix.com
Actix Analyzer Loading Ericsson GPEH files March 2009 Technical Notes
From the Tools menu, select Choose Scenario to display the Attach Load Time Queries
dialog.
www.actix.com
Actix Analyzer Loading Ericsson GPEH files March 2009 Technical Notes
www.actix.com
Actix Analyzer Loading Ericsson GPEH files March 2009 Technical Notes
www.actix.com
Actix Analyzer Loading Ericsson GPEH files March 2009 Technical Notes
Troubleshooting 8
4 Troubleshooting
The data fails to load with Full load selected
Try using Minimal load.
Try deactivating the Load all adjacent files option.
The data fails to load with Minimal load selected
Uncheck all the other scenario boxes when you use Choose Scenario.
www.actix.com
Actix Analyzer Loading Ericsson GPEH files March 2009 Technical Notes
Troubleshooting 9
www.actix.com