10 minutes is required for each session and the temperature is varies to materials. For PP it requires 230degC and for PE it requires 190degC of temperature. 5 samples needed for each session. Each sample is weight accurately.
10 minutes is required for each session and the temperature is varies to materials. For PP it requires 230degC and for PE it requires 190degC of temperature. 5 samples needed for each session. Each sample is weight accurately.
10 minutes is required for each session and the temperature is varies to materials. For PP it requires 230degC and for PE it requires 190degC of temperature. 5 samples needed for each session. Each sample is weight accurately.
and the temperature is varies to materials. For PP it requires 230°C and for PE it requires 190°C of temperature.
3) Small die head (2mm (dia)) inserted into
the mini extruders (Melt Flow Indexer) 4) Material is packed properly inside the extruder barrel to avoid formation of air pocket.
5) A piston is introduced to act as a medium
that cause extrusion of the molten polymer. The sample is pre-heated for specific amount of time: 5 min at 190°C for PE and 6 min at 230°C for PP
6) After the pre-heating, the specific amount
of weight is introduced onto the piston. 7) On account of the weight shear is exerted on the molten polymer and immediately starts flowing through the die.
8) A sample of the melt is taken after desired
period of time automatically. 5 samples needed for each session.
9) Each sample is weight accurately.
10) A certificate is release for this particular sample for viewing and kept for record.
ChatGPT Money Machine 2024 - The Ultimate Chatbot Cheat Sheet to Go From Clueless Noob to Prompt Prodigy Fast! Complete AI Beginner’s Course to Catch the GPT Gold Rush Before It Leaves You Behind