Professional Documents
Culture Documents
Objective Questions in Analog Electronics
Objective Questions in Analog Electronics
(c) large collector-base reverse bias (d) large emitter-base forward bias
3. Thermal runaway is not possible in FET because as the temperature of FET increases
(a) greater than +100 (b) slightly less than unity but positive
5. A differential amplifier has a differential gain of 20,000 . CMRR=80 dB. The common mode
gain is given by
7. An OPAMP has a slew rate of 5 V/µ S .The largest sine wave O/P voltage possible at a
frequency of 1MHZ is
(a) affects the difference mode gain Ad (b) affects the common mode gain Ac
1
OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS
9. A differential amplifier is invariably used in the i/p stage of all OP-AMPs.This is dome
basically to provide the OP-AMPs with a very high
10. The effective channel length of a MOSFET in a saturation decreases with increase in
12. In a p-n junction diode under reverse bias , the magnitude of electric field is maximum at
15. A constant current signal across a parallel RLC circuits gives an o/p of 1.4v at the signal
frequency of 3.89KHZ and 4.1KHZ .At the frequency of 4KHZ,the o/p voltage will be
16. Class AB operation is often used in power (large signal) amplifiers in order to
2
OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS
(d) Q-factor of the o/p and i/p circuits as well as quiescent operating point
18. If =0.98 ,Ico=6µA and Iβ=100µA for a transistor,then the value of Ic will be
20. Most of the linear ICs are based on the two-transistor differential amplifier because of its
a) Reduces gain
c) Reduces bandwidth
d) Increases noise
22. A dc power supply has no-load voltage of 30v,and a full-load voltage of 25v at full-load
current of 1A.Its output resistance & load regulation ,respectively are
23. The current gain of a bipolar transistor drops at high frequencies because of
3
OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS
25. An npn BJT has gm=38mA/v, cµ =10¯14 F, cπ =10¯13F and DC current gain β0=90.For this
transistor fT & fβ are
a) fT =1.64 x 108 Hz & fβ = 1.47 x 1010 Hz. b) fT =1.47 x 1010 Hz & fβ = 1.64 x 108 Hz
c) fT =1.33 x 1012 Hz & fβ = 1.47 x 1010 Hz d) fT =1.47 x 1010 Hz & fβ = 1.33 x 1012 Hz
27.An amplifier using an opamp with slew rate SR=1v/µsec has a gain of 40db.if this amplifier
has to faithfully amplify sinusoidal signals from dc to 20 KHz without introducing any slew-rate
induced distortion, then the input signal level must not exceed
28. In the differential voltage gain & the common mode voltage gain of a differential amplifier
are 48db &2db respectively, then its common mode rejection ratio is
29. Generally, the gain of a transistor amplifier falls at high frequencies due to the
30. An amplifier without feedback has a voltage gain of 50,input resistance os 1 KΩ & Output
resistance of 2.5KΩ.The input resistance of the current-shunt negative feedback amplifier using
the above amplifier with a feedbacik factor of 0.2 is
4
OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS
31. The action of JFET in its equivalent circuit can best be represented as a
32. Three identical amplifiers with each one having a voltage gain of 50,input resistance of 1KΩ
& output resistance of 250 ,are cascaded.The open circuit voltage gain of combined amplifier
is
34. In a full-wave rectifier using two ideal diodes,Vdc & Vm are the dc & peak values of the
voltage respectively across a resistive load. If PIV is the peak inverse voltage of the diode, then
the appropriate relationships for this rectifier is.
a) gm r0 b) gm / r0 c) gm rπ d) gm /rπ
37. The most commonly used amplifier in sample & hold circuits is
5
OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS
38. Assume that the op-amp of the fig. is ideal. If Vi is a triangular wave ,then V0 will be
C R
V - V0
39. Introducing a resistor in the emitter of a common amplifier stabilizes the dc operating point
against variations in
Ans:- 1. (c), 2. (b), 3. (a), 4. (a), 5. (a), 6. (d), 7. (d), 8. (b), 9. (a), 10. (b), 11. (d), 12. (c),
13. (b), 14. (c), 15. (b), 16. (c), 17. (a), 18. (d), 19. (c), 20. (d), 21. (a), 22. (b), 23. (a),
24. (a), 25. (b), 26. (b), 27. (c), 28. (c), 29. (a), 30. (a), 31. (d), 32. (c), 33. (b),
34. (b), 35. (b), 36. (c), 37. (b), 38. (c), 39. (c), 40. (c)