Professional Documents
Culture Documents
Q1.
What is the most correct clearance mentioned below between side of a panel and wall, as per standard practice? a) 190m b) 300m c) 550m What would be the best suited distance between two LV Switchgears, front facing to each other, keeping economic consideration in design? a) 2000m b) 1500m c) 800m d) 2200m
Q2.
Q3.
What is the radius of Rolling sphere to be considered for the lightning protection of structures in non-hazardous category as per British Standard? a) 20m b) 60m c) 45m d) 30m c) Earthing system c) Both d) Cable trays d) None
The term LUX is used for designing of a) Bathing soap b) Lighting system Photo cell is used for controlling the a) Outdoor Lighting b) Indoor Lighting
For earthing of equipments ( Lighting fixtures etc. ), the colour of insulation of conductor is a) Red b) Black c) Blue d) Yellow/Green
Q7.
What is the first activity of electrical arrangement engineer after handover the Project from Tendering. a. b. c. d. Create risk sheet Study tender documents, project contracts and specification Create concept documents Preparation of primary cable ways on Plot plan.
Q8.
For planning of primary cable way followings are required: a. Building sizes b. Single line diagram
c. Finalization of electrical building/area location on the plot plan d. Single line diagram Q9. It is necessary to complete the activities for preparation of civil guide drawing for E1INPUT a. b. c. d. 3D-Mdeling of buildings & GA drawing of building. 3D Modeling of duct bank/cable racks/major cable trays. Both None of them
Q10.
If ground water level is low, the drainage system in cable pulling pit provided with a) b) c) Dry & wet well Wet well Dry well
Q11.
Minimum Spacing and bending radius for 150 dia conduit a) b) c) 225mm & 1000mm 225mm & 1500mm 250mm & 1000mm
Q12. a) b) c)
Definition of minor cable route : cables routed in one route >10nos<20 nos <10 nos <15 nos