Professional Documents
Culture Documents
Remove The Engine Cover. Refer To The Appropriate Service Manual
Remove The Engine Cover. Refer To The Appropriate Service Manual
Disconnect the connector -1- from the Mass airflow sensor (G70) , and remove the Air Filter
Housing. Refer to appropriate service manual.
Zoom
Zoom
Zoom
Disconnect the Intake Air Temperature (IAT) Sensor (G42) electrical harness connector - 6 -.
Zoom
Using a Multimeter , check the Intake Air Temperature (IAT) Sensor (G42) terminals 1 to 2 for
resistance.
Zoom
Replace the Intake Air Temperature (IAT) Sensor (G42). Refer to appropriate service manual.
Go to Final procedures
Replace the Motronic Engine Control Module (ECM) (J623). Refer to appropriate service manual.
Go to Final procedures
Disconnect the Intake Air Temperature (IAT) Sensor (G42) electrical harness connector - 6 -.
Zoom
Using a jumper wire, connect the Intake Air Temperature (IAT) Sensor (G42) electrical harness
connector terminals 1 to 2.
Zoom
Replace the Intake Air Temperature (IAT) Sensor (G42). Refer to appropriate service manual.
Go to Final procedures
Remove the Motronic Engine Control Module (ECM) (J623). Refer to appropriate service manual.
Using a Multimeter, check the Intake Air Temperature (IAT) Sensor (G42) electrical harness
connector terminals to the Motronic Engine Control Module (ECM) (J623) electrical harness
connector T60 terminals for an open circuit according to the wiring diagram.
Zoom
Zoom
Check the wiring for a short circuit to Battery voltage, or an open circuit.
Check the electrical harness connector for damage, corrosion, loose or broken terminals.
Go to Final procedures
Replace the Motronic Engine Control Module (ECM) (J623). Refer to appropriate service manual.
Go to Final procedures
Disconnect the Intake Air Temperature (IAT) Sensor (G42) electrical harness connector - 6 -.
Zoom
Replace the Intake Air Temperature (IAT) Sensor (G42). Refer to appropriate service manual.
Go to Final procedures
Remove the Motronic Engine Control Module (ECM) (J623). Refer to appropriate service manual.
Using a Multimeter, check the Intake Air Temperature (IAT) Sensor (G42) electrical harness
connector terminals to the Motronic Engine Control Module (ECM) (J623) electrical harness
connector T60 terminals for an open circuit according to the wiring diagram.
Zoom
Zoom
Check the wiring for a short circuit to Battery voltage, or an open circuit.
Check the electrical harness connector for damage, corrosion, loose or broken terminals.
Go to Final procedures