Professional Documents
Culture Documents
Lecture 23 PDF
Lecture 23 PDF
Dr. N. K. Patel
Lecture: 23 Cement industries
Module: 5
Lecture: 23
7. Puzzolana cement
Puzzolana is a volcanic powder. It is found in Italy near Vesuvius. It resembles
surkhi which is prepared by burning bricks made from ordinary soils. It can also be
processed from shales and certain types of clays. Puzzolana material should be
used in between10 to 30%.
Advantage
Evolves less heat during setting
Possesses higher tensile strength
Imparts higher degree of water tightness
Attains comprehensive strength with age
Can resist action of sulfates
Imparts plasticity and workability to mortar and concrete prepared from it.
Offers great resistance to expansion
It is cheap
Disadvantages
Compressive strength in early days is less
Possesses less resistance to erosion and weathering action
This cement is used to prepare mass concrete of lean mix and for marine
structures. It is also used in sewage works and for laying concrete under water.
8. Hydrophobic cement
When hydrophobic cement is used, the line fine pores in concrete are
NPTEL 157
Module: 5
Dr. N. K. Patel
Lecture: 23 Cement industries
uniformly distributed and thus the frost resistance and the water resistance of such
concrete are considerably increased.
9. Expanding cement
It is produced by adding an expanding medium like sulfoaluminate and
establishing agent to ordinary cement. Hence this cement expands whereas other
cements shrink.
It is used for the construction of water retaining structures and for repairing
the damaged concrete surfaces.
This type of cement possesses less compressive strength. Initial setting time is
about one hour and usual setting time is about 10 hours. It is mainly used for mass
concrete work.
This cement is used for structures which are likely to be damaged by severe
alkaline conditions such as canal linings, culverts, syphons etc.
Raw materials
Basis: 1000kg of cement
Clay = 100-300kg
Limestone = 1200-1300kg
Gypsum = 30-50kg
NPTEL 158
Module: 5
Dr. N. K. Patel
Lecture: 23 Cement industries
Coal = 250-400kg
Water = 3000kg
Electricity = 80kWH
The most commonly used composition on % basis by mass for the Portland
cement manufacturing is given below
Significance of constituents
Lime
Lime is also defined as non-hydraulic cement mainly consisting of calcium
oxide and small amount of magnesium oxide. It is prepared by calcining the lime
stone (CaCO3) at temperature that it will slake, when brought in contact with water.
It is principal constituent of cement. Proper amount of lime is important as excess of
it reduces the strength as well as lesser amount also reduces the strength and makes
its quick setting. Lime is mainly used for white washing of mortar for joining bricks,
metallurgy and glass industries.
Silica
It imparts strength to cement.
Alumina
It works as an accelerator and makes the cement quick settling. However
excess of alumina makes the cement unsound.
Iron oxide
It provides colour, strength and hardness of cement.
Magnesia
If present in small amount impart hardness and colour to cement
NPTEL 159
Module: 5
Dr. N. K. Patel
Lecture: 23 Cement industries
Sulfur trioxide
If present in small amount it imparts soundness to cement but excess of it is
undesirable
Alkalis
Most of the alkalis present in raw materials are carried away by the flue gases
during heating and cement contains only a small amount of alkalis. If present in
excess causes the efflorescent to cement.
NPTEL 160