Professional Documents
Culture Documents
4. In a Y-connected balanced 3-phase circuit Vph = 208 V, p.f. =0.6, P = 300W. Zph = ? (
)
given line voltage 208V, power, pf 0.6. y-y connection balanced 3phase, find impedance on
each phase-math ( )
7. A single line diagram indicated by a point, given 6 fault current from primary and secondary
side. what type of fault to be determined. ( )
10. Determine the induction torque in a 400 V, 50 Hz, 4-pole, Y-connected induction motor
operating at 2% slip with 240W power being lost in its motor winding.
( )
Draw Vin vs Vout transfer curve of an op amp with 5v reference at negative input, sine wave in
positive input , biasing 12V, at output two zener diodes of 7V and 9V were connected face-to-
face. ( )
( )
Zener diode math with fixed load (a very tough one indeed) with PZ, IZ, IZK, RL. Find output
voltage. ( )
18. Signal power = 2 MW, Noise power = 1.95 MW. Find maximum data rate and Shanons
capacity. [Find maximum delta modulation shanons theorem (300-3300) Hz
]
20. x (t) = 1.5 cos (800t) is to be PCM with minimum SQNR of 25dB. How many bytes are
required for encoding each having uniform quantization.
21.
Rony Parvejs EEE Question Bank M.Sc. Admission Test-2014, BUET
23. Draw the block diagram of a optical fibre communication system. What type of technique is
widely used in multiplexing and what is the most common wavelength used in optical fiber now
a days.
24. a verilog code was given which was actually a Negative edge clock D-FlipFlop.
execute