Professional Documents
Culture Documents
A320 Induction With Answers PDF
A320 Induction With Answers PDF
1) The normal priority for supplying electrical power to the AC busses is:
2) What is the maximum altitude at which the APU may be started using the batteries
only?
a) 15, 000 ft
b) 30, 000 ft
c) 25, 000 ft
d) 39, 000 ft
a) No
b) Yes but only below FL150
c) Yes but only when one pack is OFF
d) Yes can be used without any restrictions.
a) 0 psi.
b) 1 psi.
c) 2 psi.
d) 8.6 psi.
Page 1 of 13
A320 Induction Technical Test
8) With the center tank pump mode SEL switch in AUTO; the center tank pumps:
c) Continue to run until five minutes after the center tank is empty before getting
latched off.
9) What does an amber line across the last two digits of the fuel quantity mean?
Page 2 of 13
A320 Induction Technical Test
c) A disagreement between fuel measured and fuel entered on the MCDU has
been detected.
11)After engine start, center tank fuel pumps run for ______ minutes regardless of slat
position.
a) 1 minute.
b) 2 minutes.
c) 3 minutes.
d) 5 minutes.
a) Green system
b) Blue system.
c) Green with yellow system as backup.
d) Yellow system
Page 3 of 13
A320 Induction Technical Test
a) Green system
b) Blue system.
c) Green with yellow system as backup.
d) Yellow system
15)The parking brake accumulator is designed to maintain the parking pressure for at
least ______.
a) 6 hours.
b) 12 hours.
c) 18 hours.
d) 24 hours.
a) Blue
b) Green
c) Yellow
d) Both a & b
17)Which of the following are the sources for Yellow Hydraulic system Pressurization?
Page 4 of 13
A320 Induction Technical Test
a) Engine Driven Pump, Yellow Electric Pump, Cargo Door Handle , Green
System using the PTU.
b) Engine Driven Pump, Yellow Electric Pump, RAT , Green System using
the PTU.
c) Engine Driven Pump, RAT, Cargo Door Handle , Green System using
the PTU.
d) Engine Driven Pump, Yellow Electric Pump, Cargo Door Handle , RAT
18)The PTU comes into action automatically when the differential pressure between
the GREEN and the YELLOW systems is greater than ______ psi.
a) 300
b) 500
c) 650
d) 700
19)When does RAT deploy automatically?
d) None of above
21)When the flight control law is in direct law which of the following is displayed on
PFD?
Page 5 of 13
A320 Induction Technical Test
c) Both a & b
22)In Alpha floor condition, which of the following statements are correct.
d) Both b & c.
23)For latching the side sticks priority condition, and for releasing the sidestick without
losing authority, it is recommended to press the takeover pushbutton for more than
______ seconds.
a) 3 seconds
b) 40 seconds
c) 45 seconds
d) 10 seconds
a) SECs
b) SFCCs
c) FACs
Page 6 of 13
A320 Induction Technical Test
25)Being in alternate law , when the Landing gear is extended control laws change to
a) Normal Law
b) Direct law
c) Mechanical back up
a) EPR
b) N1
c) N2
d) Fuel Flow
Page 7 of 13
A320 Induction Technical Test
a) Yes, FADEC has authority to abort the start in case of abnormal start.
c) Yes, FADEC has authority to abort the start in case of Ignition fault only.
31)During In-flight Auto start, will the automatic start abort function be available.
a) Yes, FADEC has authority to abort the start in case of in flight abnormal start.
c) Yes, FADEC has authority to abort the start in case of EGT Over limit in flight.
a) 100 kts
b) 70 kts
c) 80 kts
d) 90 kts
33)On the ground, CVR is stopped automatically ______ after the last engine shutdown.
Page 8 of 13
A320 Induction Technical Test
a) Immediately
b) 1 minute
c) 3 minutes
d) 5 minutes.
b) Minimum time.
c) Best ratio between the flight time cost and the fuel cost.
36)The weather radar image can be displayed on which modes of the ND?
Page 9 of 13
A320 Induction Technical Test
a) FCU.
b) Thrust Levers.
c) MCDU.
a) FMGC
b) MCDU
c) ADIRU
40)After a single DMC failure, how could a crew member recover the display units?
a) It is done automatically.
c) Rotate the EIS DMC switch on the switching panel to replace the failed DMC with
DMC #3.
Page 10 of 13
A320 Induction Technical Test
d) Yes. E/WD information is automatically transferred to the the F/O's PFD in the
event of an ECAM warning.
43)The lower end of a red and black strip along the speed scale defines the VMAX
speed.
Page 11 of 13
A320 Induction Technical Test
c) Flight Director commands for pilot to control pitch, roll and yaw
a) Push and hold one instinctive disconnect pushbutton for more than 15 secs.
b) Push and hold one instinctive disconnect pushbutton for more than 60 secs.
47) Do not depress IDG Disconnect switch for more than to prevent
damage to the disconnect mechanism.
a) 3 secs
b) 10 secs
c) 60 secs
Page 12 of 13
A320 Induction Technical Test
b) Mix IRS position and the computed radio position or GPS position.
Page 13 of 13