Professional Documents
Culture Documents
Wrfu-Huawei PDF
Wrfu-Huawei PDF
WRFU
One WCDMA radio frequency unit (WRFU) supports 40 W (2 carriers) and 80 W (4 carriers) power outputs.
Panel
Function
The direct frequency conversion technique, which is directly implemented in the transmit channel, modulates the baseband
signals to WCDMA RF signals. After being filtered and amplified, the RF signals are transmitted to the antenna for
transmission through the duplex filter.
The uplink RF signals received from the antenna go through down-conversion, amplification, analog-to-digital conversion,
digital down-conversion, matched filtering, automatic gain control (AGC). Then, they are sent to the BBU for further
processing.
Power control and Voltage Standing Wave Ratio (VSWR) detection
Reverse power detection
Frequency synthesis and loopback test
Generation of the CPRI clock, recovery of the CPRI clock of lost synchronization, and alarm detection
The WRFU supports 40 W (2 carriers) and 80 W (4 carriers) power outputs.
Principle
1 of 4 9/25/2010 2:05 PM
WRFU http://127.0.0.1:52199/hedex/pages/574119981/05 (2009-08-20)/574119...
The WRFU consists of the high-speed interface unit, signal processing unit, power amplifier, and duplex unit. Figure 2 shows the principle
of the WRFU module.
Figure 2 Principle of the WRFU
Transmitting the signals received from the BBU to the signal processing unit
Transmitting the signals received from the signal processing unit to the BBU
The signal processing unit consists of two uplink RX channels and one downlink TX channel.
The power amplifier amplifies the low-power RF signals from the signal processing unit.
The functions of the duplexer are as follows:
LED
2 of 4 9/25/2010 2:05 PM
WRFU http://127.0.0.1:52199/hedex/pages/574119981/05 (2009-08-20)/574119...
RUN ON steady The power input is normal, but the module is faulty.
0.125s ON, 0.125s OFF The module is loading software or is not started.
3 of 4 9/25/2010 2:05 PM
WRFU http://127.0.0.1:52199/hedex/pages/574119981/05 (2009-08-20)/574119...
Port
CPRI CPRI0 SFP female Connecting the BBU, or the upper-level WRFU during the
connector cascading
CPRI1 SFP female Connecting the lower-level WRFU during the cascading
connector
Interconnection port for RX_INB QMA female Input port of diversity signals in the antenna channel
RF receive signals connector
RX_OUTA QMA female Output port of diversity signals in the antenna channel
connector
4 of 4 9/25/2010 2:05 PM