Professional Documents
Culture Documents
Good3 PDF
Good3 PDF
I have neither given nor received any unauthorized assistance on this project.
Design Summary
• Supply: 1 V
• Topology:
Folded cascode differential amplifier + push-pull output stage
2
Schematic of Op-Amp
Note: DC current under loaded, zero AC input
condition with common-mode voltage of 500 mV. I3 = 9.224 uA I4 = 9.243 uA
Iout = 60.31uA
I1 = 15.3 uA
I2 = 3.27 uA
I5 = 15.3uA I6 = 15.2 uA
214 pA
vout
Open loop gain and differential PSRR: use two vdc sources, one as
gain: use vdc with DC magnitude of VDD and one as GND. The VDD
80mV and AC magnitude of 1; source should have DC of 1. Then, set
perform AC analysis of Vout VDD (but not GND) to AC magnitude
Note: For unloaded diff gain, the 1 and perform AC analysis at Vout for
setup is identical to the top setup in PSRR+; set GND (but not VDD) to AC
CMRR, i.e. without the load in the magnitude of 1 and perform AC
above figure) analysis at Vout for PSRR-
9
Differential Gain and Phase
Differential
Gain
Phase
Common-Mode
Rejection Ratio
Common-Mode Gain
Vout
Vin
Vin Vout
Vin Vout
15
Power Supply Rejection Ratio
PSRR-
PSRR+
• PSRR+ = -54.13 dB
• PSRR- = -8.622 dB 16
Noise