Professional Documents
Culture Documents
Bwanmunarmramanm
Tandon School of Engineering
Mechanical and Aerospace Engineering Department
Fall 2018
Lab Instructor
arrammmmrumm
ME - UY 4214: Finite Element Design, Model, and Analysis
Mhfffffhounummmm
Industry Assistant Professor
Room # RH 502B, Mechanical & Aerospace Engineering Department
Ph: 646 997 4081, Email: ddl268@nyu.edu
Format
The report must be submitted with the ID on the cover page.
All symbols must be defined clearly.
All tables and figures come with the caption.
The report is submitted with the PDF format; Word or other formats are not
accepted.
Assignment
New York University
Fall 2018
Note:
mmmmhammm
ME - UY 4214: Finite Element Design, Model and Analysis
Lab Assignment 2
Problem#1
A long thick-walled cylinder is maintained at a temperature Ti on the inner surface and To on the
outer surface. Determine the temperature distribution through the wall thickness. Also determine the
tangential stress σt at the inner and outer surfaces and the maximum the radius stress σr. Compare the
maximum and minimum values of the tangential and longitudinal stresses.
Requirements:
Solve problem in 2D and 3D models.
Using the symmetric model for 3D problem (No credit for others)
Provide the temperature at x = 0.2788 in
Hand calculation results: t r a 420 psi , t r b 194 psi and r max 87 psi
(S. Timoshenko, Strength of Material, Part II, Elementary Theory and Problems)
Problem#2 (Biomechanical Engineering)
The object of this problem is finding the development of the trabecular/cortical bone surrounding the
dental implant as depicted in the following figure. The bone development is defined by four strain
windows as shown in the below table. Determine the volume percentage of each strain window in the
region of interest.
4 mm
11 mm
Requirements:
The original research was presented in “Influence of Clinically Relevant Factors on the
Immediate Biomechanical Surrounding for a Series of Dental Implant Designs” by
Shunmugasamy, V.S. et al. Review this paper to define the boundary conditions and more
information.
Use one cortical bone model with 4 mm thickness.
Set the Young’s modulus of trabecular bone to 4 GPa.
Use the equivalent elastic strain to generate the results.
Hints:
The implant model and the reference paper are attached in the current folder.
In order to calculate the volume percentage of strain result, the following steps should be
used:
o Generate the result of the equivalent strain for the region of interest.
o Change the parameter in “Display Option” from “Averaged” to “Elemental Mean”
in the detailed view.
o Export the equivalent strain result to the excel file.
o Use that file to calculate the volume percentage after sorting the equivalent strain
values from smallest to biggest.
Review the article at https://en.wikipedia.org/wiki/Dental_implant for more information
about the dental implant.