Professional Documents
Culture Documents
LENGTH
Video notes: The videos contain sound, so make sure to turn your computer’s speakers on
during use of the CD. These video files do not require a special player for them to run,
and are played in “full-screen” mode (alt + Enter). To access the player’s functions
(pause, stop, fast-forward etc.) hit the “Esc.” Key while the video is playing.
1. CP/TP Gview (13:39 41,621K) This video describes the geometry view,
construction plane, and tool plane in Mastercam, and how to change them. The
levels manager is also discussed.
2. Job Setup (7:55 18,883K) This video discusses the use of the Job Setup in
Mastercam including using the materials library.
3. Operations Manager (9:53 26,199K) The operations manager is shown. Group
operations, copying toolpaths are discussed.
5. Exercise 2 (5:30 12,825K) This exercise uses polar lines for construction
geometry. The Xform Rotate function is used.
6. Exercise 3 (11:39 29,203K) This is an intermediate 2D drawing exercise.
Several methods of arc creation are used.
7. 3D Wireframe (8:07 21,409K) This is a simple 3D wireframe exercise covering
the use of different construction planes.
8. Surfaces (23:09 67,129K) This example covers modeling a hair dryer using
several surface creation functions.
9. Solids (6:33 22,839K) This is an example of a plastic cap modeled using the
solid modeling functions in Mastercam.
683399
Exercise 1
Exercise 2
Exercise 3
3D Wireframe Exercise