Professional Documents
Culture Documents
Department of Education
Region VIII
BORONGAN CITY DIVISION
STA. FE NATIONAL HIGH SCHOOL
Sta. Fe, Borongan City
TEST II Match items on Column A with Column B. Write only letter that corresponds to your answer.
___ 32. A magnetic storage device that is installed inside the B. Flash drive or Thumb drive
computer.
___ 33. Early drive controller interface that connects computers and C. Read-only memory
hard disk drives which an interface that uses a 40-pin connector.
___ 34. Temporary storage for data and programs that are being D. IDE
accessed by the CPU.
___ 35. A storage device that uses lasers to read data on the optical E. Floppy drive
media.
___ 36. A storage device that uses removable 3.5inch disks. F. Random success memory
___ 37. Soldered the memory chips on a special circuit board. G. Optical drive
___ 38. A removable storage device that connects to a USB port. H. DDR
___ 39. Memory cells built right into the CPU that contain specific data I. Hard drive
needed particularly the Arithmetic and Logic Unit
___ 40. Technology that doubles the maximum bandwidth of SDRAM. J. Memory module
TEST III.
Direction: Read each statement below carefully. Place T on the line, if you think a statement is TRUE. Place
F, if you think the statement is FALSE.
_____41Selecting the best tool for each task requires training in the proper use of the tools, field experience
in their safe use, and following the manufacturer’s guidance and instructions for that specific tool.
_____ 42. When obtaining the tool, all the associated tooling and consumable parts, as recommended by
the manufacturer, must be included.
_____ 43. The safe use of a tool depends on using the tool for the purpose for which it was designed and also
for other purposes where it can be used as substitute where tool is not available.
_____ 44. All tools should be kept in good condition with regular maintenance.
_____ 45. Preparing for a task includes only knowing the task to be done.
_____ 46. It is recommended that operators avoid spending more than five hours a day on keyboard duties
and no longer than 50 minutes per hour without a postural/stretching break.
_____ 47. To detect whether there are reflections from the desk surface, the worker should hold the book
below the surface and assess the change in reflected glare from the screen.
_____ 48. 10,000 - 12,000 keystrokes per hour is considered an acceptable standard in typing.
_____ 49. Good posture is essential for all users of computers.
_____ 50. The solution is to increase the refresh rate of the monitor to at least 75hz.
Test II
1. I 2. D 3. F 4. G 5. E 6. J 7. B 8. C 9. A 10. H
Test III
T, T, T, T, F, T, F, T, T